Volvo C30 2007 Service And Repair Manual page 417

the receiver together with 3 M8 screws. Tighten.

the pipe couplings, 2 x M8. Make sure the O-rings are securely located. Tighten the screws.

the M8 nut below the fender liner. Tighten.

the fender liner together with the plastic nut and the retaining clip.

FINISHING
CHECKING THE FUNCTION AND LEAK TRACING
Vacuum pump the air conditioning (A/C) system. See: VACUUM PUMPING .
Fill the air conditioning (A/C) system with refrigerant. See: REFRIGERANT, FILLING .
Leak trace the air conditioning (A/C) system. See: LEAK DETECTION, TRACER AGENT , LEAK
TRACING, ELECTRONIC LEAK TRACER (2007, 2010-11) or LEAK TRACING, ELECTRONIC
LEAK TRACER (2008-09) .
INSTALLING COMPONENTS AND CHECKING PERFORMANCE
Install:
the bumper cover. See: COVER BUMPER FRONT (2007 - 2011 EARLY) or COVER BUMPER

FRONT (2011 LATE - 2012)
right-hand front headlamp. See: HEADLAMP BULB (2007) or HEADLAMP BULB (2008-2012) .

Carry out a performance test on the climate control unit. See: CLIMATE CONTROL SYSTEM, CHECK .
ELECTRIC BOOSTER HEATER (2007)
NOTE: The illustrations in this service information are used for different model years
and/or models. Some variation may occur. However, the essential information in
the illustrations is always correct.
PREPARATORY WORK
REMOVING COMPONENTS
Remove center console. See: REMOVING CENTER CONSOLE.
REMOVAL
REMOVING THE ELECTRICAL PREHEATER
2012 Volvo C30 T-5
HVAC Climate Units - Removal, Replacement And Installation