Club Car Carryall 500 2016 Maintenance And Service Manual page 424

23
Fueling Instructions – Gasoline Vehicle
DANGER
• If the vehicle has an all-weather enclosure installed, be sure the fuel tank is properly vented as shown
in Figure 23-16.
• To avoid the possibility of fire, clean up any spilled fuel before operating the vehicle.
CAUTION
• Use unleaded gasoline only.
• Whenever possible, avoid using oxygenated and blended fuels.
• Do not use any fuel with an alcohol content that exceeds 10% by volume (such as E15 and E85).
Ethanol is an alcohol that readily absorbs moisture, causing corrosion of fuel system components. It
also damages neoprene and other plastic and rubber components. Use of these fuels in this vehicle
will void the warranty.
• Do not repeatedly attempt to start a vehicle when the fuel pump is dry (no gas in tank). Doing so
can damage the fuel pump.
NOTE: Whenever possible, avoid using oxygenated fuels and fuels that are blended with alcohol. Vehicles to be
stored for extended periods should be prepared for storage as instructed. See Preparing the Gasoline
Vehicle for Extended Storage on page 3-4.
1. Remove the fuel cap located on the passenger-side panel and fill the fuel tank with fresh unleaded gasoline only.
See preceding CAUTION and NOTE.
2. Replace fuel cap on tank. Ensure cap is tightened securely (tighten until it clicks).
1. Vent 2. Fuel Vent Line 3. Fuel Tank
2832
Figure 23-16 Fuel Tank
Page 23-26 2016 Carryall 500 and 700 Maintenance and Service Manual
1
2
3
FUEL SYSTEM: GASOLINE VEHICLES