Yamaha XT 600 AC Service Manual page 236

FRONT AND REAR BRAKE
I C HASI
~I
6-35
NOTE: ________________________ __
Install the brake hose as shown .
AWARNING
• Proper hose routing is essential to insure
safe motorcycle operation.
Refer to the "CABLE ROUTING" in the
CHAPTER 2.
• Always use new copper washers.
4 . Install :
• Brake switch
CD
.Spring
®
• Brake lever
®
• Protecter (right)
• Mirror (right)
NOTE: ________________________ __
Apply lithium soap base grease to pivot shaft of
brake lever .
5. Fill :
• Brake fluid
Recommended Brake Fluid:
If DOT # 4 is not available,
DOT
#
3 can be used.
CAUTION:
Brake fluid may erobe painted surfaces or
plastic parts . Always clean up spilled fluid
immediately.
AWARNING
• Use only the designated quality brake fluid:
otherwise , the rubber seals may deterio-
rate, causing leakage and poor brake per-
formance.
• Refill withe the same type of brake fluid;
mixing fluids may result in a harmful chem-
ical reaction and lead to poor performance .
• Be careful that water does not enter the
master cylinder when refilling. Water will
signifi c antly lower the boiling point of the
fluid and may result in vapor lock.
6. Air bleed :
• Brake system
Refer to the "AIR BLEEDING" section in
the CHAPTER 3 .