Fuel Line; Carburetor; Clutch; Idle Rpm - Suzuki Katana 1100 Service Manual

2-9 PERIODIC MAINTENANCE AND TUNE-UP PROCEDURES
FUEL LINE (FUEL LINE AND VAPOR
HOSE... California Version only)
~-;-~~~;-;t-I-~iti~-IY
at 1000 km (600 miles.- 2 months) and
Every 6000 km (4000 miles. 12 months) thereafter.
I
i
Replace Every four years.
L_______________ _ _
CARBURETOR
IDLE RPM (Idling adjustment)
Inspect Initially at 1000 km-
(600~iles~2-mon~hs)
and
Every 6000 km (4000 miles.
~~ months~~_~r_:~~:r
J I
NOTE:
Make this adjustment when the engine is hot.
• Connect a tachometer.
• Start up the engine and set its speed at anywhere between
1000 and 1200 r/min by turning throttle stop screw
CD.
Engine idle speed: 11 00
t~
100 r/min
THROTTLE CABLE PLAY
There should be 0.5 - 1.0 mm (0.02 - 0.04 in) play
®
on the
throttle cable. Adjust the throttle cable play with the following
procedure.
• Loosen the lock nut and turn the adjuster
®
in or out until
the specified play is obtained.
• Tighten the lock nut while holding the adjuster.
Throttle cable play @: 0.5 - 1.0mm (0.02 - 0.04in)
WARNING:
After the adjustment is completed. check that handlebar
rnovemen t does not raise the engine idle speed and that the
throttle grip returns smoothly and automatically.
CLUTCH
Inspect Initially at 1000 km (600 miles. 2 months) and
Every 6000 km (4000 miles, 12 months) thereafter.
Replace hose every four years. Replace fluid every two
I
years.
_____________________J
I
CLUTCH FLUID LEVEL
• Keep the motorcycle upright and place the handlebars
straight.
• Check the clutch fluid level in the reservoir.
• If the level is found to be lower than the lower mark, replenish
with BRAKE Fl UID that meets the following specification.
Specification and classification: DOT4
(Continued
011
next page.)