Reeves G2 series Operation Manual page 105

Operation & Maintenance w/IPB
REMOVE AND REPLACE FUEL FILTER/WATER SEPARATOR PROCEDURES
INITIAL SETUP:
Tools and Special Tools
General Mechanics Tool Kit
Materials/Parts
Waste Fuel Container or Equivalent
Fuel Drain Hose or Equivalent
Clean Rags
REMOVAL FUEL FILTER/WATER SEPARATOR ASSEMBLY:
1. Disconnect the power cord from the power supply.
2. Attach drain hose to the fuel water separator bowl drain valve.
3. Open drain valve and drain fuel into a fuel waste container.
4. Using a 9/16" open end wrench or equivalent, loosen the fuel in-line at the fuel water separator housing
(loosening this fuel line will assist in draining the fuel water strainer assembly).
5. Loosen and remove the fuel water strainer assembly by turning the assembly in a CCW direction. Drain
remaining fluid from the fuel water strainer.
REMOVAL OF FUEL FILTER:
6. Hold the fuel filter/water separator bowl in one hand; loosen and remove fuel filter by turning the filter in a
CCW direction.
7. Recycle or discard the old fuel filter.
8. Remove the fuel water separator bowl o-ring.
INSTALLATION OF FUEL FILTER:
1. Lubricate and install new fuel filter/water separator bowl o-ring
2. Install new fuel filter onto the fuel water separator bowl by turning filter in a CW direction. Hand tight only.
INSTALLATION OF FUEL FILTER/WATER SEPARATOR ASSEMBLY:
3. Using a 9/16" open end wrench or equivalent, tighten the fuel in-line at fuel water separator housing.
4. Hand tighten fuel water separator bowl drain valve.
5. Reconnect power cord to power supply outlet.
6. Perform operations and leak checks.
END OF TASK
Part Number: 1006375
This document contains information proprietary to DHS Systems LLC and is intended solely for use by its customers. No portion of this document may be reproduced
for release to a third party without written consent of DHS Systems LLC.
G2 Series Decontamination Water Heater
PROCEDURES REQUIRE VERIFICATION
Personnel Required
One
Equipment Condition
Equipment Powered Down
Power Source Disconnected
0015-17
0015
DHS Systems LLC