Advertisement
1) The battery electrolyte must not have the below "LOWER" level. It may cause short life,
heat generation and explosion.
2) Only put purified water into the battery. (Do not replenish with dilute sulfuric acid.)
If impurities are put in, it may cause heat generation, ignition, and generation of toxic gas.
3) If too much purified water (distilled water) is put in, the electrolyte may spill and cause
metal corrosion.
the battery fluid, be sure to wash it with water.
4) After replenishing water, install the inlet port plug firmly so that no liquid leaks.
7.4.2 How to auxiliary charge.
If the engine does not start even if the battery level is controlled, or if the rotation of the starter
motor is lower and weaker than usual, the battery was discharged. Follow the procedure below
Minus first
Do
not
contact
plus and
minus
Do not fill more than UPPER (maximum liquid level). If you should spill
for charging for 5 to 10 hours.
・Battery removal procedure
① Stop the engine of this product and remove the key.
② Make a note of the battery installation status (terminal
polarity position).
③ Loosen the bolt on the "-" (minus) terminal of the unit and
disconnect the cable terminal from the "-" (minus) terminal
of the battery.
④ Then, loosen the bolt of the "+" (plus) cable terminal and
disconnect the cable from the battery "+" (plus) terminal.
⑤
Loosen the battery mounting bracket and remove the
battery horizontally. Handle the battery carefully as it is a
heavy item.
・auxiliary charge
① Before using the charger, make sure that the power is
turned off. If it is connected to the battery while it is ON, a
spark will be generated, which may cause ignition or
explosion.
② Connect the + (plus) side of the charger to the + (plus) side
of the battery, and theー(minus) side of the charger to theー
(minus) side of the battery. Incorrect connection may cause
electric circuit failure or wiring damage.
③ Take out all 6 liquid inlet cap.
※An optional charger is required.
〈7.4.5 Reference, Battery charging time〉
7. 点検表
Advertisement
