Table of Contents
Advertisement
Section 5 – Procedures
5.6-2 Replace the Fuel Filter
1. Remove the bolt securing the engine tray to the
turret.
2. Pull the locking pin down and swing the engine
tray away from the turret.
3. Close the fuel shut-off valve.
4. Place a suitable container under the fuel filter.
5. Remove the fuel filter and catch any escaping
fuel.
WARNING
Dispose of fuel in accordance with local and
federal regulations.
6. Clean any dirt from filter carrier sealing surface.
7. Apply a thin layer of oil or diesel fuel to the
rubber gasket of the new fuel filter.
8. Install the fuel filter and tighten it by hand, then
tighten the filter cartridge with final half-turn.
9. Clean up any fuel that may have spilled during
this procedure.
10. Open the fuel shut-off valve.
11. Check for fuel leakage.
12. Swing the engine tray back to its original
position.
13. Reinstall the engine tray bolt.
5.6-3 Replace the Air Filter
Engine specifications require that this procedure be
performed more often if dusty conditions exist. Refer
to the engine manual.
CAUTION
Perform this procedure with the engine off.
1. Remove the mounting fasteners from the air filter
canister, and remove the end cap.
2. Remove the filter from inside of the canister.
3. Clean the inside of the canister and gasket with
a dry cloth.
4. Insert a new filter into the canister.
5. Reinstall the end cap.
229044ADA
170
5.6-4 Check the Engine Belt
The MEWP will not operate properly with a loose
or defective belt. Continuous usage may cause
component damage.
WARNING
Do not inspect the fan belt while the engine is
running. Remove the key to prevent accidental
operation.
1. Inspect the engine belt for:
cracking
▪
glazing
▪
separation
▪
breaks
▪
2. For correct tension of the engine belt, refer to
the engine manual.
5.6-5 Check the Oil Cooler (Deutz D2011
only)
1. Remove the cover from the side of the engine.
2. Inspect the oil cooler for leaks and physical
damage.
3. Clean the oil cooler of any kind of debris.
4. Reinstall the cover.
Deutz Diesel Engines
SJ85 AJ
Advertisement
Table of Contents
