JLG 600SC Service And Maintenance Manual page 84

SECTION 3 - CHASSIS & TURNTABLE
SPN
4768
4769
4769
4769
4769
4769
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
5763
520521
523008
523008
523009
523009
523090
523211
523212
523213
523216
523240
523330
523330
523330
523330
523330
523350
3-38
Table 3-1. Deutz Trouble Codes (TD2.9 L4 Engine)
FMI
2 Exhaust gas temperature sensors up and downstream DOC are physically swapped
2 Temperature downstream DOC, plausibility error
3 Sensor error exhaust gas temperature downstream (DOC); signal range check high
4 Sensor error exhaust gas temperature downstream (DOC); signal range check low
2 Sensor exhaust gas temperature OxiCat downstream (normal operation); plausibility error
2 Sensor exhaust gas temperature OxiCat downstream (regeneration); plausibility error
6 Actuator error EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8).
Signal range check high.
7 Actuator position for EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8) not plausible.
6 Actuator error EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); signal range check high
5 Actuator error EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); signal range check low
3 Position sensor error of actuator EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8).
Signal range check high.
4 Position sensor error actuator EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8).
Signal range check low.
5 Actuator EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); open load
6 Actuator EGR-Valve (2.9;3.6) or Throttle-Valve (6.1,7.8); over current
3 EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); short circuit to battery
3 EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); short circuit to battery
4 EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); short circuit to ground
4 EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); short circuit to ground
6 Actuator error EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); Overload by short-circuit
11 Power stage over temperature due to high current.
4 Actuator AGR valve (2.9;3.6) throttle valve (4.1;6.1;7.8); Voltage below threshold.
0 Warning threshold for an internal actuator error exceeded, < 4L EGR.actuator und >4L Air Intake Flap
1 Shut off threshold for an internal actuator error exceeded, < 4L EGR.actuator und >4L Air Intake Flap
5 Actuator error EGR-Valve (2.9;3.6) or Throttle-Valve (4.1;6.1;7.8); signal range check low.
1 Manipulation control was triggered
2 Timeout error in Manipulation control
9 The pressure relief valve (PRV) has reached the number of allowed activations.
10 Open time of Pressure Relief Valve (PRV) for wear out monitoring had exceeded
2 Engine Brake Pre-Selection switch; Plausibility Error
9 Timeout Error of CAN-Receive-Frame EBC1
9 Timeout Error of CAN-Receive-Frame ComEngPrt; Engine Protection
12 Timeout Error of CAN-Transmit-Frame ERC1 No detail information
9 Timeout Error of CAN-Receive-Frame PrHtEnCmd; pre-heat command, engine command
9 Timeout CAN-message FunModCtl; Function Mode Control
14 Immobilizer status; fuel blocked
14 DFC to block the fuel by Sia No detail information
14 DFC to indicate that TEN-code or UC-code received if ECU is learned.
No detail information
14 DFC to indicate that no code is received via CAN. No detail information
14 DFC to indicate that wrong code is received. No detail information
4 Injector cylinder-bank 1; short circuit
Error Identification
3121776