JLG 600SC Service And Maintenance Manual page 78

SECTION 3 - CHASSIS & TURNTABLE
SPN
174
175
175
175
175
175
190
190
190
190
190
190
190
190
190
190
411
411
411
411
411
412
412
520
598
624
624
624
624
630
630
630
639
651
651
652
652
653
653
654
654
3-32
Table 3-1. Deutz Trouble Codes (TD2.9 L4 Engine)
FMI
11 DFC for fuel temperature plausibility check function. No detail information
3 Sensor error oil temperature; signal range check high
4 Sensor error oil temperature; signal range check low
0 High oil temperature; warning threshold exceeded
0 High oil temperature; shut off threshold exceeded
2 Customer oil temperature: signal unplausible
0 Engine speed above warning threshold
Over speed detection in component engine protection
0 Engine speed above warning threshold (FOC-Level 1)
11 Engine speed above warning threshold (FOC-Level 2)
14 Engine speed above warning threshold (Overrun Mode)
8 Sensor camshaft speed; disturbed signal
12 Sensor camshaft detection; out of range, signal disrupted; no signal
2 Offset angle between crank- and camshaft sensor is too large.
8 Sensor crankshaft detection; out of range, signal disrupted; disturbed signal
12 Speed detection; out of range, signal disrupted Sensor crankshaft speed; no signal
14 Camshaft- and Crankshaft speed sensor signal not available on CAN
4 Physical range check low for EGR differential pressure
0 Delta pressure across venturi in EGR line above physical high limit
0 Plausibility Check fault for deviation of desired and actual EGR-mass flow, where the latter is calculated out of EGR Delta
Pressure Sensor
3 Sensor error differential pressure Venturiunit (EGR), signal range check low.
4 Sensor error differential pressure Venturiunit (EGR), signal range check high.
3 Electrical error EGR cooler downstream temperature. Signal range check high.
4 electrical error EGR cooler downstream temperature. Signal range check low.
9 Timeout Error of CAN-Receive-Frame TSC1TR; control signal
2 Plausibility check for Clutch. No detail information
5 SVS lamp; open load
12 SVS lamp: power stage over temperature
3 SVS lamp; short circuit to battery
4 SVS lamp; short circuit to ground
12 Access error EEPROM memory (delete)
12 Access error EEPROM memory (read)
12 Access error EEPROM memory (write)
14 CAN-Bus 0 "BusOff-Status"
5 Injector 1 (in firing order); interruption of electric connection
3 Injector 1 (in firing order); short circuit
5 Injector 2 (in firing order); interruption of electric connection
3 Injector 2 (in firing order); short circuit
5 Injector 3 (in firing order); interruption of electric connection
3 Injector 3 (in firing order); short circuit
5 Injector 4 (in firing order); interruption of electric connection
3 Injector 4 (in firing order); short circuit
Error Identification
3121776