Changing Engine Oil And Oil Filter, Cleaning Engine Oil Screen; Draining Engine Oil, Cleaning Engine Oil Screen; Removing The Oil Filter - KTM 400 EXC AUS 2011 Repair Manual

381lUBRICATION SYSTEM
182
Condition
Engine is cold.
- Check the engine oil level.
The engine oil must be between the halfway mark and the top of the oil level
viewer •.
>
If the engine oil level is below the specified level:
- Add engine oil.
(r
p. 184)
Cbanlinl ena;ine ail and aillilter, cleaninl enline ail screen
- Drain the engine oil and clean the engine oil screen.
( r
p. 182)
- Remove the oil filter. (r p. 182)
- Install the oil filter.
(r
p. 183)
- Fill up with engine oil.
(r
p. 183)
30148~10
Draininllnlinl oil, cllaninllnlinl ail serlIn
Warning
Danger of scalding
Engine oil and gear oil get very hot when the motorcycle is ridden.
- Wear appropriate protective clothing and safety gloves. In case of burns, rinse immediately with lukewarm water.
Warnina:
Environmental hazard
Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.
Info
Drain the engine oil only when the engine is warm.
- Stand the motorcycle on its side stand on a horizontal surface.
- Place a suitable container under the engine.
- Remove engine oil plug screen
O.
- Completely drain the engine oil.
- Thoroughly clean the plug and engine oil screen.
- Clean the sealing surface on the engine.
- Mount and tighten the engine oil screen drain
plug •.
Guideline
PI ug, engi ne oi I screen
M17x1.5
Warning
Danler of scalding
Engine oil and gear oil get very hot when the motorcycle is ridden.
20 Nm
(14.8 Ibf
tt)
- Wear appropriate protective clothing and safety gloves. In case of burns, rinse immediately with lukewarm water.
Warnina:
Environmental hazard
Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.
381lUBRICATION SYSTEM
182
Condition
Engine is cold.
- Check the engine oil level.
The engine oil must be between the halfway mark and the top of the oil level
viewer •.
>
If the engine oil level is below the specified level:
- Add engine oil.
(r
p. 184)
Cbanlinl ena;ine ail and aillilter, cleaninl enline ail screen
- Drain the engine oil and clean the engine oil screen.
( r
p. 182)
- Remove the oil filter. (r p. 182)
- Install the oil filter.
(r
p. 183)
- Fill up with engine oil.
(r
p. 183)
30148~10
Draininllnlinl oil, cllaninllnlinl ail serlIn
Warning
Danger of scalding
Engine oil and gear oil get very hot when the motorcycle is ridden.
- Wear appropriate protective clothing and safety gloves. In case of burns, rinse immediately with lukewarm water.
Warnina:
Environmental hazard
Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.
Info
Drain the engine oil only when the engine is warm.
- Stand the motorcycle on its side stand on a horizontal surface.
- Place a suitable container under the engine.
- Remove engine oil plug screen
O.
- Completely drain the engine oil.
- Thoroughly clean the plug and engine oil screen.
- Clean the sealing surface on the engine.
- Mount and tighten the engine oil screen drain
plug •.
Guideline
PI ug, engi ne oi I screen
M17x1.5
Warning
Danler of scalding
Engine oil and gear oil get very hot when the motorcycle is ridden.
20 Nm
(14.8 Ibf
tt)
- Wear appropriate protective clothing and safety gloves. In case of burns, rinse immediately with lukewarm water.
Warnina:
Environmental hazard
Hazardous substances cause environmental damage.
- Oil, grease, filters, fuel, cleaners, brake fluid, etc., should be disposed of as stipulated in applicable regulations.