Rotax 915 i A SERIES Maintenance Manual page 63

TOPICS IN THIS CHAPTER
Engine check after propeller strike incidents ..........................................................................................2
Removal of the propeller gearbox ...........................................................................................................2
Removal of the drive gear ......................................................................................................................6
Installation of propeller gearbox ..............................................................................................................8
Examination after engine failure ............................................................................................................14
Returning engine to service after submerging in water............................................................................15
Inspection in extreme climatic conditions ...............................................................................................16
Diminished functional capability of EMS ................................................................................................16
Returning engine to service after influence by fire ..................................................................................17
Exceeding of max. admissible engine RPM ...........................................................................................17
Exceeding of max. coolant temperature.................................................................................................19
Non compliance with the coolant specification .......................................................................................20
Exceeding the max. permissible oil temperature ....................................................................................22
Oil pressure below minimum value........................................................................................................23
Oil specification not respected ..............................................................................................................26
Spark plug not in accordance with specification .....................................................................................28
Non compliance of fuel quality ..............................................................................................................28
Smooth performance of the engine .......................................................................................................29
Sudden drop in boost pressure and speed.............................................................................................30
Sudden increase in boost pressure and speed.......................................................................................31
Periodic rise and fall in boost pressure and speed (vibration of turbo control
unit)....................................................................................................................................................31
Lightning strike....................................................................................................................................32
Reporting............................................................................................................................................33
Introduction Special checks must be carried out immediately in the event of an engine fault (e.g.
abnormal operation as defined in the Operators Manual) which impairs the airworthiness
of the engine.
In the course of special checks specify if additional checks for components (e.g.
Effectivity: 915 i A Series
Edition 0/Rev. 0
MAINTENANCE MANUAL
Chapter: 05-50-00
UNSCHEDULED MAINTENANCE CHECKS
hydraulic governor) is applicable. After each special check/repair work, an
engine test run and a leakage check must be carried out.
Observe without fail all the specified instructions.
BRP-Rotax
ATTENTION
ATTENTION
05-50-00
Page 1
December 01 2017