50 - 300 Hour Maintenance Interval - Polaris PREDATOR 50 2009 Manual

50 - 300 Hour Maintenance Interval

Periodic Maintenance Chart
Item
General Lubrication
Valve Clearance
E
Carburetor Float Bowl
Throttle Cable /
E ETC Switch
Choke Cable
E
E Carburetor Intake Flange
Brake Shoe Wear
Drive Belt
Fuel System
E
Fuel Filter
E
Engine Mounts
Exhaust Muffler / Pipe
Ignition Timing
E
Wiring
Clutches (Drive
and Driven)
Front Wheel Bearings
Spark Arrestor
Toe Adjustment
Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
Have an authorized Polaris dealer perform these services.
Maintenance Interval
(whichever comes first)
Hours Calendar Miles (KM)
50 H 3 M 500 (800)
50 H 3 M 500 (800)
50 H 6 M 500 (800)
50 H 6 M 500 (800)
50 H 6 M 500 (800)
50 H 6 M 500 (800)
50 H 6 M 500 (800)
50 H 6 M 500 (800)
100 H 12 M 1000 (1600)
100 H 12 M 1000 (1600) Replace yearly
100 H 12 M 1000 (1600) Inspect
100 H 12 M 1000 (1600) Inspect
100 H 12 M 1000 (1600) Inspect
100 H 12 M 1000 (1600)
100 H 12 M 1000 (1600) Inspect;clean; replace worn parts
100 H 12 M 1000 (1600) Inspect; replace as needed
300 H 36 M 3000 (4800) Clean out
-
-
Lubricate all grease fittings, pivots, & cables
Check clearance; adjust to specification if
required; perform break-in adjustment after the
first 10 hours of operation
Drain bowl periodically and prior to storage
Inspect; adjust; lubricate; replace if necessary
Inspect; adjust; lubricate; replace if necessary
Inspect for proper sealing / air leaks
Inspect; replace as needed
Inspect; replace as needed
Check for leaks at tank cap, lines, fuel valve,
filter, carburetor, replace lines every two years
Inspect for wear, routing, security; apply
dielectric grease to connectors subjected to
water, mud, etc.
Inspect periodically; adjust when parts are
-
replaced
MAINTENANCE
Remarks
2.5
2