Final Confirmation Test - Suzuki GRAND VITARA JB416 Service Manual

10B-6 Body Electrical Control System:

Final Confirmation Test

Confirm that the problem symptom has gone and the body electrical control system is free from any abnormal
conditions. If what has been repaired is related to the malfunction DTC, check DTC again and confirm that no DTC is
indicated.
Scan Tool Data
Scan tool Data
Vehicle Speed
Outside air Temp
Battery Voltage
Coolant Temp
Engine Speed
Fuel Consumption
Key Reminder Sw
Door key Sw
Door Lock Sw
Driv Door Sw
Pass Door Sw
Brake Fluid Level
Parking Brake Sw
Rear Defogger Sw
Tail Light Sw
Driv Seat belt Sw
Charge Light
Oil pressure switch
A/C Switch
Rear Wiper Sw
Front Fog Light Sw
Headlight Sw
At stop with ignition switch turned ON
Reference value is relative to outside air temperature
At specified idle speed after warming up
At specified idle speed after warming up
Engine idling with no load applied after warming up
At specified idle speed after warming up
Ignition key inserted in ignition key cylinder
Ignition key pulled out from ignition key cylinder
Key cylinder switch of driver side door at lock position
Key cylinder switch of driver side door not turned
Key cylinder switch of driver side door at unlock position
Lock side of manual door lock switch pressed
Manual door lock switch not pressed
Unlock side of manual door lock switch pressed
Driver side door open
Driver side door closed
Doors other than driver side door open
Doors other than driver side door closed
Brake fluid level at MIN level or higher
Brake fluid level lower than MIN level
Parking brake lever pulled
Parking brake lever released
Rear end door window defogger switch turned ON with engine
running
Rear end door window defogger switch turned OFF with engine
running
Lighting switch at HEAD or CLEARANCE position
Lighting switch at OFF position
Driver side seat belt fastened
Driver side seat belt unfastened
Engine at stop with ignition switch turned ON
Engine running
Engine at stop with ignition switch turned ON
Engine running
A/C and ignition switch turned ON
A/C switch turned OFF
Rear wiper switch at ON position
Rear wiper switch at INT position
Rear wiper switch at OFF position
Lighting switch at HEAD or CLEARANCE position and front fog
light switch at ON position
Lighting switch at HEAD or CLEARANCE position and front fog
light switch at OFF position
Lighting switch at HEAD position
Lighting switch at OFF position
Condition
S5JB0EA204003
Normal condition /
reference value
0 km/h
–40 °C – 70 °C
(–40 °F – 158 °F)
10 – 14 V
80 °C – 100 °C
(176 °F – 212 °F)
Desired idle speed
± 50 rpm
0.0 km/l
Key in
Pulled
LOCK
Neutral
Unlock
LOCK
Neutral
Unlock
Open
Close
Open
Close
Normal
Low
ON
OFF
ON
OFF
ON
OFF
Fasten
Unfasten
ON
OFF
ON
OFF
ON
OFF
ON
INT
OFF
ON
OFF
ON
OFF