Suzuki GRAND VITARA JB416 Service Manual page 18

1-vi Table of Contents
General Description ............................................. 1H-*
Ignition System Construction .............................. 1H-*
Schematic and Routing Diagram........................ 1H-*
Ignition System Wiring Circuit Diagram............... 1H-*
Component Location ........................................... 1H-*
Ignition System Components Location................ 1H-*
Diagnostic Information and Procedures............ 1H-*
Ignition System Symptom Diagnosis................... 1H-*
Reference Waveform of Ignition System............. 1H-*
Ignition System Check ........................................ 1H-*
Ignition Spark Test .............................................. 1H-*
Repair Instructions .............................................. 1H-*
High-Tension Cord Removal and Installation
(For M16 Engine) .............................................. 1H-*
High-Tension Cord Inspection (For M16
Engine).............................................................. 1H-*
Spark Plug Removal and Installation .................. 1H-*
Spark Plug Inspection ......................................... 1H-*
Ignition Coil Assembly (Including ignitor)
Removal and Installation................................... 1H-*
Ignition Coil Assembly (Including ignitor)
Inspection.......................................................... 1H-*
Ignition Timing Inspection ................................... 1H-*
Specifications....................................................... 1H-*
Tightening Torque Specifications........................ 1H-*
Special Tools and Equipment ............................. 1H-*
Starting System ..........................................1I-*
Precautions.............................................................1I-*
Cranking System Note ..........................................1I-*
General Description ............................................... 1I-*
Cranking Circuit Introduction................................. 1I-*
Starting Motor Circuit Description .........................1I-*
Diagnostic Information and Procedures.............. 1I-*
Cranking System Symptom Diagnosis.................. 1I-*
Starting Motor Performance Test ..........................1I-*
Repair Instructions ................................................1I-*
Starting Motor Dismounting and
Remounting.........................................................1I-*
Starting Motor Components .................................. 1I-*
Starting Motor Inspection ......................................1I-*
Specifications.........................................................1I-*
Starting Motor Specifications ................................1I-*
Tightening Torque Specifications..........................1I-*
Special Tools and Equipment ............................... 1I-*
Recommended Service Material ........................... 1I-*
Charging System ...................................... 1J-*
General Description ..............................................1J-*
Battery Description ............................................... 1J-*
Generator Description .......................................... 1J-*
Diagnostic Information and Procedures .............1J-*
Battery Inspection ................................................ 1J-*
Generator Symptom Diagnosis ............................ 1J-*
Generator Test (Undercharged Battery
Check)................................................................ 1J-*
Generator Test (Overcharged Battery
Check)................................................................ 1J-*
Repair Instructions ...............................................1J-*
Jump Starting in Case of Emergency................... 1J-*
Battery Dismounting and Remounting ................. 1J-*
Water Pump and Generator Drive Belt
Removal and Installation (For M16 Engine)....... 1J-*
Water Pump and Generator Drive Belt
Tension Inspection and Adjustment (For
M16 Engine)....................................................... 1J-*
Water Pump and Generator Drive Belt
On-Vehicle Inspection (For J20 Engine) ............ 1J-*
Water Pump and Generator Drive Belt
Removal and Installation (For J20 Engine) ........ 1J-*
Generator Dismounting and Remounting............. 1J-*
Generator Components........................................ 1J-*
Generator Inspection............................................ 1J-*
Specifications ........................................................1J-*
Charging System Specifications .......................... 1J-*
Tightening Torque Specifications......................... 1J-*
Exhaust System........................................ 1K-*
General Description ............................................. 1K-*
Exhaust System Description ............................... 1K-*
Diagnostic Information and Procedures ............ 1K-*
Exhaust System Check ....................................... 1K-*
Repair Instructions .............................................. 1K-*
Exhaust System Components ............................. 1K-*
Exhaust Manifold Removal and Installation
(For M16 Engine Model) ................................... 1K-*
Exhaust Manifold Removal and Installation
(For J20 Engine Model)..................................... 1K-*
Exhaust Pipe and Muffler Removal and
Installation ......................................................... 1K-*
Specifications ....................................................... 1K-*
Tightening Torque Specifications........................ 1K-*
Special Tool ........................................................ 1H-*