Operation Procedure For Charging A/C With Refrigerant - Suzuki GRAND VITARA JB416 Service Manual

Operation Procedure for Charging A/C with Refrigerant

WARNING
!
• Your eyes should not be exposed to refrigerant (liquid).
Any liquid Refrigerant-134a escaping by accident shows a temperature as low as approx. –6 °C (21.2
°F) below freezing point. Should liquid HFC-134a (R-134a) get into your eyes, it may cause a serious
injury. To protect your eyes against such accident, it is necessary to always wear goggles. Should it
occur that HFC-134a (R-134a) strikes your eye(s), consult a doctor immediately.
– Do not use your hand to rub the affected eye(s). Instead, use quantities of fresh cold water to
splash it over the affected area to gradually raise temperature of such area above freezing point.
– Obtain proper treatment as soon as possible from a doctor or eye specialist.
• Should the liquid refrigerant HFC-134a (R-134a) is exposed to your skin, the affected area should be
treated in the same manner as when skin is frostbitten or frozen.
• Do not handle refrigerant near any place where welding or steam cleaning is performed.
• Refrigerant should be kept in a cold and dark place. It should never be stored in any place where
temperature is high, e.g. where exposed to direct sun light, close to fire or inside vehicle (including
trunk room).
• Avoid breathing fume produced when HFC-134a (R-134a) is burned. Such fume may be hazardous to
your health.
Check A/C system f Chec
leaks and amount of refriger leaks and amount of refr
charged. charged.
Repair Instructions
Start e Star t evacuation. acuation.
20 min 20 minutes (abo utes (above 760 mmHg)
Stop evacuation. Stop e acuation.
Wait 10 min ait 10 minutes utes
Check A/C system f Chec k A/C system for or
pressure tighteness pressure tighteness.
Recharge A/C system with Recharge A/C system with
refriger refr igerant. ant.
k A/C system for refr or refriger igerant ant
igerant ant
Perf erfor ormance test mance test
e 760 mmHg)
Inspect and repair connections. Inspect and repair connections
If gauge shows If gauge sho ws
abnormal conditions abnor mal conditions
Recharge 570 Recharge 570
refriger refr igerant. ant.
Air Conditioning System:
30 g of 30 g of
7B-5
S5JB0E7206001
I5JB0A720031-02