Nilfisk-Advance Advance Retriever 2060 Service Manual page 81

FRONT
14 14 14 14 14 Use the Cable Ties (O) (O) to secure the wires. (O) (O)
(O)
15 15 15 15 15 Check to be sure coolant is at the proper
level.
16 16 16 16 16
Reconnect the battery, start the machine and
check the new gauges for proper operation.
FIGURE 6 FIGURE 6
FIGURE 6 FIGURE 6 FIGURE 6
Z
Q
F
E
Diesel Diesel Diesel Diesel Diesel
Coolant Temperature
• • • • • Drain a portion of the coolant from the radiator to prevent
losing the fluid when the pipe plug is removed from the en-
gine block.
• • • • • See Figure 6. See Figure 6.
See Figure 6. Locate and remove Pipe Plug (Z) See Figure 6. See Figure 6.
block and install Temperature Sender (G)
Plug is located on intake side of the engine block near the
back and top. Hook up wire (Q)
and re-fill the radiator.
Oil Pressure
• • • • • See Figure 7. See Figure 7. Locate and remove the Oil Sender (AA) See Figure 7.
See Figure 7. See Figure 7.
move the Kubota Fitting (BB)
a 1/8-27 NPT pipe tap to clear the threads to accept the el-
(P) (P)
bow (P) (P) (P). Thoroughly clean and reinstall the Kubota part, in-
sure that seal washers are in place.
• • • • • Install Elbow (P)
elbow away from the alternator so that the Oil Pressure
Sender (F) (F) (F) (F) (F) can be installed without interference. Then in-
stall oil pressure sender into Elbow (P)
• • • • • Connect the White Wire (E)
(F) (F) (F). Tape the ring terminal on the GRA/BLK wire that was (F)
(F)
removed from the old oil pressure sender. Secure the wire
G
to the wiring harness. Go to step 14.
FIGURE 7 FIGURE 7
FIGURE 7 FIGURE 7 FIGURE 7
AA
BB
P
Chase thread with
(page 5 of 6)
(G) (G)
(G) (G). Use pipe sealant.
(Q) (Q) (Q) to the temperature sender (Q)
(BB) from the engine block and use (BB) (BB)
(BB)
(P) (P) (P) (P) into modified Kubota Fitting (BB)
(P) (P) (P). (P)
(E) (E) (E) (E) to the new Oil Pressure Sender
FRONT
Kubota Parts
1/8-27 NPT tap
4/99 revised 8/01 Form No. 56040693
(Z) (Z)
(Z) (Z) from engine
(AA). Re- (AA) (AA)
(AA)
(BB) point the (BB) (BB) (BB)