Run-In And Economical Driving - Seat Toledo 2019 Owner's Manual

damage to the vehicle and cause acci-
dents and severe injuries.
Never ignore the warning lamps or mes-
●
sages.
Stop the vehicle at the next opportunity
●
and in a safe place.
Run-in and economical driv-
ing
The first 1,500 km
Over the first 1,500 kilometres the engine
must be run in.
Up to 1000 kilometres
Do not drive at more than 3/4 of the maxi-
–
mum speed corresponding to the engaged
gear, i.e. up to 3/4 of the maximum permit-
ted engine speed.
Do not drive at full speed.
–
Avoid high engine speeds.
–
Do not tow a trailer.
–
From 1000 to 1500 kilometres (600 to
900 miles)
Slowly increase the engine speed until
–
reaching the maximum permitted speed of
210
Driving
the engaged gear, i.e. the maximum permit-
ted engine speed.
During its first few hours of running, the inter-
nal friction in the engine is greater than later
on, when all the moving parts have bedded
in. How the vehicle is driven over approxi-
mately the first 1,500 kilometres (900 miles),
determines the success of the process of run-
ning in the engine.
Even after running in, the vehicle should not
be unnecessarily driven at high engine
speeds. The maximum permitted engine
speed is marked at the start of the red zone
on the rev counter dial. The gear must be
changed up when the red area is reached in
vehicles with a manual gearbox. Extremely
high engine speeds when accelerating are
automatically limited, however the engine is
not protected against high engine speeds
produced by incorrectly changing to a lower
gear, which could cause the engine to run at
revs above the maximum permitted amount,
and consequently result in damage to the
engine.
Additionally, vehicles with a manual gearbox
must also bear the following in mind: do not
drive at excessively low speeds. Change
down to a lower gear when the engine no
longer runs smoothly. Observe the recom-
›››
mendations for changing gear
New tyres
New tyres must be submitted to "running in",
given that initially their grip is not yet at the
maximum level. During the first 500 km (120
miles) drive very carefully.
New brake pads
New brake pads do not yet provide maximum
friction capacity. First they must be "run in".
During the first 200 km (120 miles) drive very
carefully.
CAUTION
All the information for speed and engine
speed refers to an engine that operates at
operating temperature. Do not run the en-
gine at high engine speeds, neither when
stopped or while driving.
For the sake of the environment
Do not drive at unnecessarily high engine
speeds; changing to a higher gear sooner
contributes to saving fuel, reduces operat-
ing noise and protects the environment.
Environmental compatibility
Environmental protection is a top priority in
page 208.
the design, choice of materials and manufac-
ture of your new SEAT.