Removing The Fuel Tank; Removing The Fuel Pump; Checking The Fuel Pump Body; Checking The Fuel Pump Operation - Yamaha FZ09E 2014 Service Manual

EAS1RC1701

REMOVING THE FUEL TANK

1. Extract the fuel in the fuel tank through the
fuel tank cap with a pump.
2. Remove:
• Rider seat
• Air scoop/Fuel tank cover
Refer to "GENERAL CHASSIS" on page 4-1.
3. Disconnect:
• Fuel hose (fuel tank side)
• Fuel pump coupler
• Fuel tank drain hose
• Fuel tank breather hose
EWA1RC1702
WARNING
Cover fuel hose connection with a cloth
when disconnecting them. Residual pres-
sure in the fuel lines could cause fuel to
spurt out when removing the hose.
ECA1RC1707
NOTICE
Be sure to disconnect the fuel hose by hand.
Do not forcefully disconnect the hose with
tools.
TIP
• To remove the fuel hose from the fuel pump,
slide the fuel hose connector cover "1" on the
end of the hose in the direction of the arrow
shown, press the two buttons "2" on the sides
of the connector, and then remove the hose.
• Before removing the hose, place a few rags in
the area under where it will be removed.
• It is prohibited to wear the cotton work gloves
or equivalent coverings.
4. Remove:
• Fuel tank
TIP
Do not set the fuel tank down so that the instal-
lation surface of the fuel pump is directly under
the tank. Be sure to lean the fuel tank in an up-
right position.
EAS26640

REMOVING THE FUEL PUMP

1. Remove:
• Fuel pump
ECA14720
NOTICE
• Do not drop the fuel pump or give it a
strong shock.
• Do not touch the base section of the fuel
sender.
EAS1RC1702

CHECKING THE FUEL PUMP BODY

1. Check:
• Fuel pump body
Obstruction  Clean.
Cracks/damage  Replace fuel pump as-
sembly.
EAS26690

CHECKING THE FUEL PUMP OPERATION

1. Check:
• Fuel pump operation
Refer to "CHECKING THE FUEL PRES-
SURE" on page 7-11.
EAS1RC1718
CHECKING THE ROLLOVER VALVE (for
California only)
1. Check:
• Rollover valve "1"
Damage/faulty  Replace.
TIP
• Check that air flows smoothly only in the direc-
tion of the arrow shown in the illustration.
• The rollover valve must be in an upright posi-
tion when checking the airflow.
EAS1RC1703

INSTALLING THE FUEL PUMP

1. Install:
• Fuel pump gasket
• Fuel pump
• Fuel pump bracket
• Fuel pump bolts
7-3
FUEL TANK
1
New