Checking The Fuel Pump Relay 950 Adventure/950 Supermoto; Checking The Ignition Coils 950 Adventure/Supermoto/Super Enduro - KTM 2003 950 Adventure Repair Manual

7-17
A
B
1
2
3

Checking the fuel pump relay 950 Adventure/950 Supermoto

– Dismount the fuel pump relay
Supermoto).
NOTE: black/blue, blue/gray, yellow/black and brown cable colors
– Connect the fuel pump relay to a 12 V battery as shown, making
sure you hear the relay switch (nonrecurring "click").
NOTE: the 12 V battery must be connected to the two terminals to
which the blue/gray and brown cable colors are connected when the
plug is connected.
– Use an ohmmeter to measure the continuity between the terminals
and .
A B
Reading: max. 1
Reading: ∞

Checking the ignition coils 950 Adventure/Supermoto/Super Enduro

– Disconnect and remove the ignition coil
– Use an ohmmeter to obtain the following measurements:
Resistance of the primary coil (measured between the terminals):
1.0 – 1.6
Resistance of the secondary coil (measured between one terminal and
the spark plug connector: 9.4 – 17.6 K
NOTE:
– Repeat the measurement for the other ignition coil.
– Replace the respective ignition coil if the measurement deviates
significantly from the set point value.
(950 Adventure) and
1 2
Ω
OK
Ω
defective
.
3
Ω
at 20°C
Ω
at 20°C
(950