Related Manuals for KTM 990 Supermoto R 2011
Summary of Contents for KTM 990 Supermoto R 2011
- Page 1 SETUP INSTRUCTIONS 2011 990 Supermoto R EU 990 Supermoto R FR 990 Supermoto R AUS/UK 990 SUPERMOTO R USA Art. no. 3211733en...
- Page 3 KTM accepts no liability for delivery options, deviations from illustrations and descriptions, as well as misprints and other errors.
-
Page 4: Means Of Representation
MEANS OF REPRESENTATION Symbols used The symbols used are explained in the following. Indicates an expected reaction (e.g. of a work step or a function). Indicates an unexpected reaction (e.g. of a work step or a function). Identifies a page reference (more information is provided on the specified page). Denotes additional information or tips. - Page 5 SET‑UP Unpacking and setting up the vehicle – Remove the carton. – Remove the adhesive tape in the upper area of the motorcycle. 101201-10 – Roll down the film at the sides. Info To avoid damaging the motorcycle during unpacking, leave the other films on the vehicle until you have finished work on the vehicle.
- Page 6 SET‑UP – Position the hand brake cylinder. Tighten the screws. Guideline Remaining chassis screws 10 Nm (7.4 lbf ft) – Position the throttle grip. Tighten the screws. Guideline Remaining chassis screws 5 Nm (3.7 lbf ft) – Mount and tighten the right handlebar weight. Guideline Remaining chassis screws 10 Nm (7.4 lbf ft)
- Page 7 – Remove the protective plastic. 101212-01 – Refuel. ( p. 8) – Print out the current PDI form found on KTM DEALER.NET and perform the delivery inspection. – Set kilometers or miles. ( p. 9) – Set the clock. (...
-
Page 8: Mounting The Seat
– Do not discard batteries with the household trash. Dispose of a defective battery in an environmentally compatible manner. Give the battery to your KTM dealer or to a recycling center that accepts used batteries. Warning Environmental hazard Hazardous substances cause environmental damage. - Page 9 WORK – Connect the battery charger to the battery. Switch on the battery charger. Battery charger (58429074000) You can also use the battery charger to test the rest potential and start potential of the battery, and to test the alternator. With this device, you cannot overcharge the battery.
- Page 10 WORK Closing the filler cap – Put the filler cap back on and turn the ignition key 90° clockwise. – Remove the ignition key and fold down the cover. 101102-01 Refueling Danger Fire hazard Fuel is highly flammable. – Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no fuel is spilt, especially on hot vehicle components.
-
Page 11: Setting Kilometers Or Miles
WORK – Press the SET button for two seconds. The low fuel warning lamp goes out. TRIP F is set to 0.0 and the display returns to the previous display mode. Info If the SET button is not pressed, the value is automatically reset after ... -
Page 12: Technical Data - Chassis Tightening Torques
TECHNICAL DATA - CHASSIS TIGHTENING TORQUES – Remaining frame bolts EJOT Delta PT 50x12 1.2 Nm (0.89 lbf ft) – Remaining frame bolts EJOT PT K50x12 T20 1.2 Nm (0.89 lbf ft) – Remaining frame bolts EJOT PT K50x18 T20 2 Nm (1.5 lbf ft) –... - Page 13 TECHNICAL DATA - CHASSIS TIGHTENING TORQUES ® Screw, lower subframe M10x1.25 45 Nm (33.2 lbf ft) Loctite 243™ ® Screw, upper subframe M10x1.25 45 Nm (33.2 lbf ft) Loctite 243™ – Oil drain plug with magnet M12x1.5 25 Nm (18.4 lbf ft) ®...
- Page 14 SUBSTANCES Super unleaded (ROZ 95/RON 95/PON 91) According to – DIN EN 228 (ROZ 95/RON 95/PON 91) Guideline – Only use unleaded super fuel that matches or is equivalent to the specified fuel grade. – Fuel with an ethanol content of up to 10 % (E10 fuel) is safe to use. Info Do not use fuel containing methanol (e.
- Page 15 *3211733en* 3211733en KTM-Sportmotorcycle AG 5230 Mattighofen/Austria http://www.ktm.com...
Need help?
Do you have a question about the 990 Supermoto R 2011 and is the answer not in the manual?
Questions and answers