Precautions With Consumables - Panasonic DP-3510 Service Manual

6.2.

Precautions with Consumables

(1) Photoreceptor Drum
Do not touch the surface (with your hands or anything else).
Stand the drum with the drum gear facing upward during storage.
- Be careful not to smear the surface with saliva, water, oil, etc.
- Do not store in places where the temperature is high.
- Do not store it in strong light (such as direct sunlight or on the window).
- Do not expose it to chemical gas or vapor.
- Do not store the drum unit with the photoreceptor drum installed without covering
it with clean paper.
(2) Toner Developer
1) Do not mix different types of toner and developer.
- The machines are designed to use exclusive toner and developer for specific
models. Be careful not to use toner and developer from other models.
2) Do not mix foreign materials.
Be careful not to contaminate toner and developer with foreign materials. If
you spill toner or developer on a table or floor when adding toner or developer
in the developer unit, discard what was spilled. Such supplies may damage the
drum as well as cause other image problems.
3) Do not place into other containers.
Toner and developer must not be placed into other containers, as some
containers may change the characteristics of the supplies. Vinyl chloride
potentially changes the characteristics of supplies due to migrating
plasticizers.
4) Precautions during storage and transportation
- Toner and developer additives are sensitive to temperature and humidity (high
temperature or humidity in particular).
- Store toner and developer in a dark and cool location (lower than 95 ˚F/35 ˚C)
and out of direct sunlight.
- Be careful not to expose toner and developer to rain or direct sunlight during
transportation. When delivered by truck the temperature inside must not
exceed 104 ˚F/40 ˚C. (Under the sun in summer, the inside temperature
can typically be 140 ˚F/60 ˚C or higher in a closed vehicle compartment.)
- In cold climate, store in a low humidity environment condition.
Do not store supplies near heaters.
Ver. 5.2
DP-3510/3520/3530/4510/4520/4530/6010/6020/6030
267
JAN 2006