Daewoo KORANDO Service Manual page 570

CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless otherwise
noted.
Specifications . . . . . . . . . . . . . . . . . . . . . . . 1F1-2
Fastener Tightening Specifications . . . . . . . . 1F1-2
Special Tools . . . . . . . . . . . . . . . . . . . . . . . 1F1-3
Special Tools Table . . . . . . . . . . . . . . . . . . . . 1F1-3
Schematic and Routing Diagrams . . . . . . . 1F1-4
E32 ECU (MSE) . . . . . . . . . . . . . . . . . . . . . . 1F1-4
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . 1F1-5
Self Diagnosis Socket Pin Numbers and
Descriptions . . . . . . . . . . . . . . . . . . . . . . . . 1F1-5
Self Diagnosis Failure Code . . . . . . . . . . . . . 1F1-6
Test Box Connection . . . . . . . . . . . . . . . . . . . 1F1-9
Fuel Injection System Test (MSE 3.62) . . . . 1F1-10
Ignition System Test . . . . . . . . . . . . . . . . . . 1F1-20
Idling Control and Electronic Pedal
System Test . . . . . . . . . . . . . . . . . . . . . . . 1F1-25
Air Conditioner Control System Test . . . . . . 1F1-27
Fuel Pressure and Internal Leakage Test . . 1F1-28
Fuel Pump Test . . . . . . . . . . . . . . . . . . . . . . 1F1-30
SECTION 1F1
M162 ENGINE CONTROLS
TABLE OF CONTENTS
Injector Test . . . . . . . . . . . . . . . . . . . . . . . . 1F1-32
Maintenance and Repair . . . . . . . . . . . . . 1F1-34
On-Vehicle Service . . . . . . . . . . . . . . . . . . . . 1F1-34
ECU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1F1-34
Fuel Pressure Regulator . . . . . . . . . . . . . . 1F1-45
Fuel Distributor . . . . . . . . . . . . . . . . . . . . . . 1F1-49
Injector . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1F1-53
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 1F1-56
Fuel Pump . . . . . . . . . . . . . . . . . . . . . . . . . 1F1-57
Purge Switchover Valve . . . . . . . . . . . . . . . 1F1-61
Vacuum System . . . . . . . . . . . . . . . . . . . . . 1F1-63
Crankshaft Position Sensor . . . . . . . . . . . . 1F1-64
Camshaft Position Sensor . . . . . . . . . . . . . 1F1-66
Hot Film Air Mass (HFM) Sensor . . . . . . . . . 1F1-68
Oxygen Sensor . . . . . . . . . . . . . . . . . . . . . . 1F1-71
Knock Sensor . . . . . . . . . . . . . . . . . . . . . . . 1F1-73
Coolant Temperature Sensor . . . . . . . . . . . 1F1-74
Accelerator Pedal Module . . . . . . . . . . . . . . 1F1-77