Mailbox Vertical Sensor / Bin 1 Sensor Off Jam Rap - Xerox DocuColor 12/DCCS50 Service Manual

• Drive Belt (PL 18.10)
Check the Drive Belt Tension Roll for proper tension.
Finisher/Sorter
11-115 Mailbox Vertical Sensor / Bin 1 Sensor On Jam

11-116 Mailbox Vertical Sensor / Bin 1 Sensor Off Jam RAP

The Mailbox Vertical Sensor did not detect the Trail edge of the paper within the specified time
after the Mailbox Vertical Sensor detected the lead edge of the same paper.
Initial Actions
Refer to BSD12.5 and BSD12.17 for the following procedure.
Check for the following:
• Obstructions in the Mailbox paper path
• Bent or out of position paper chutes/guides in the Mailbox paper path
• Ensure that the Mailbox front Door is closed properly, in order to provide proper nip pres-
sure to the Vertical Transport Rolls.
• Ensure that connectors
and P/J1024, on the Mailbox Vertical Sensor is seated correctly and there are no obvious
crimped or broken wires.
Procedure
The trail edge of the paper is past the Mailbox Vertical Sensor
Y N
Enter dC330 012-005 Mailbox Drive Motor. Press Start. The Mailbox Transport Roll is
rotating.
Y N
The Mailbox drive Belt is moving.
Y N
The Mailbox Drive Motor is rotating
Y N
+24 VDC is measured between P/J1021-1 and P/J1021-2, 4, 6 of the
Mailbox Drive Motor
Y N
Go to
circuit. If the wires are good, replace the Mailbox PWB
Press Stop. +5 VDC is measured between P/J1021-3 and GND.
Y N
Go to
circuit. If the wires are good, replace the Mailbox PWB
Press Start. Less than +1 VDC is measured between P/J1021-3 and
GND.
Y N
Replace the Mailbox PWB
replace the Finisher PWB
Replace the Mailbox Drive Motor
Ensure that the Mailbox Drive Motor Pulley is fastened to the motor shaft.
• Check the Drive Belt Tension Roll for proper tension.
• Check the Drive Belt for Damage
A B
1/05
8d-12
manuals4you.com manuals4you.com
P/J1004 on the Mailbox PWB, P/J1022
Flag 2 and Flag 3 on BSD12.5. Check the wires for an open
Flag 1 and Flag 2 on BSD12.5. Check the wires for an open
(PL 18.11). If the problem continues,
(PL 18.4).
(PL 18.10).
DocuColor 12/DCCS50
double plug, P/J1023
(PL 18.11).
(PL 18.11).
Reissue