General Information; Special Tools; Electrical Service Notes; Components Under Hood - Polaris RANGER XP 900 2013 Manual

GENERAL INFORMATION

SPECIAL TOOLS

PART
TOOL DESCRIPTION
NUMBER
Fluke™ 77 Digital Multimeter
PV-43568
PV-43526 Connector Test Kit
Timing Light
2870630
2460761 Hall Effect Sensor Probe Harness
Static Timing Light Harness
2871745
Battery Conductance Analyzer
PU-50296
(MDX-610P)
Relay Bypass
PU-49466
- Digital Wrench® (see Chapter 4)
Bosch Automotive Service Solutions:
1-800-345-2233 or http://polaris.service-solutions.com/

ELECTRICAL SERVICE NOTES

Keep the following notes in mind when diagnosing an
electrical problem:
• Refer to wiring diagram for stator and electrical
component resistance specifications.
• When measuring resistance of a component that has a
resistance value under 10 Ohms, remember to
subtract meter lead resistance from the reading.
Connect the leads together and record the resistance.
The resistance of the component is equal to tested
value minus the lead resistance.
• Become familiar with the operation of your meter. Be
sure leads are in the proper jack for the test being
performed (i.e. 10A jack for current readings). Refer to
the Owner's Manual included with your meter for more
information.
• Voltage, amperage, and resistance values included in
this manual are obtained with a Fluke™ 77 Digital
Multimeter (PV-43568). This meter is used when
diagnosing electrical problems. Readings obtained
with other meters may differ.
• Pay attention to the prefix on the multimeter reading
(K, M, etc.) and the position of the decimal point.
• For resistance readings, isolate the component to be
tested. Disconnect it from the wiring harness or power
supply.

COMPONENTS UNDER HOOD

The following components can be accessed under the
hood.
• Voltage Regulator (in front of radiator)
• Terminal Block
9924880 Rev 2- 1/10/2014 - 2013 / 2014 RANGER XP 900 - 2014 RANGER XP 900 / CREW 900 Service Manual
© Copyright Polaris Sales Inc.
• Headlight Connectors

COMPONENTS BEHIND DASH PANEL

The following components can be accessed with the
upper dash panel removed.
• Instrument Cluster (Speedometer)
• AWD/2WD/TURF Switch
• Headlight Switch
• 12 VDC Accessory Power Points
• Ignition Key Switch
COMPONENTS UNDER PASSENGER SEAT
BASE
The following components can be accessed with the
passenger seat base removed.
• Battery*
• Battery Cables*
• Starter Solenoid*
• Relays*
• Fuses*
• Digital Wrench ® Diagnostic Connector*
• ECU*
• Speed Key Accessory (if installed)
NOTE
*Components are located under rear passenger seat
base on 2014 RANGER CREW 900
ELECTRICAL
10
10.3