Before Putting Into Service; During Operation - HAKO Scrubmaster B400 R Operating Manual

1.5.2

Before putting into service

• Before initially starting up the machine, charge the used battery fully and
appropriately with commissioning charge. Please observe the operating
manual of the charger and the operating manual of the battery manufac-
turer. Hako assumes no liability for battery damage resulting from insuffi-
cient commissioning charge.
• Check proper condition and operating safety of the machine before every
start-up! Do not use the machine as long as there are defects. Eliminate
faults and defects immediately.
• Before starting work, the operating staff must familiarise themselves with all
equipment, operating and actuating elements as well as with their function.
It is too late to do this during operation!
• Before starting up, adjust the driver's seat so that the pedals can be
operated safely and in a relaxed manner.
• Before starting up, adjust the height of the steering wheel to ensure a
comfortable and relaxed hand and arm position.
• Before turning the machine off, always switch off all drives.
1.5.3

During operation

• When working with the machine, pay special attention to third persons,
especially children.
• When driving over thresholds, all working units must be switched off
beforehand.
• Excessive quantities of dust must be avoided when working with the pre-
sweep suction unit!
• Switch on the warning device (BlueSpot, flashlight, acoustic warning
reverse gear, etc.) (option) during all work and when transporting or moving
the machine.
• When transporting the machine, raise the squeegee and the brush unit.
• Adapt the driving style and speed to the ambient conditions, the local condi-
tions and the load condition of the machine.
• Three-wheeled vehicles have lower driving stability than four-wheeled
vehicles and therefore tend to have a higher risk of tilting over. The
following measures should be observed:
• Avoid sudden steering movements at higher speeds or excessive
speeds when turning.
• Only turn the machine on level surfaces.
• When driving uphill, downhill or across slopes, avoid sudden turns and
drive slowly into the bend.
Scrubmaster B400 R (7190)
Safety instructions
15