Transmission, Installing - Volkswagen Golf 2015 Repair Manual

– Carefully lower the transmission with the Engine and Gearbox
Jack - VAS6931- , while making sure that the right flange shaft
seal -1- is guided through without any damage to the pressure
plate -arrow-.
– Guide the left flange shaft -B- past the subframe -arrow- as
shown. Move the Engine and Gearbox Jack with the trans‐
mission to the front.
– When lowering, change position of transmission with spindles
on Transmission Support - 3282- .
– Reinsert the right flange shaft if necessary and tighten the bolt
-arrow- to the tightening specification.
Note
Pay attention to the lines when lowering the transmission.
Transmission, transporting. Refer to
⇒ 4 Transmission, Transporting , page 89
Tightening Specification
♦ Flange shaft to transmission. Refer to
⇒ 2.1 Overview - Differential , page 189
2.2

Transmission, Installing

Caution
This procedure contains mandatory replaceable parts. Refer
to component overview prior to starting procedure.
Mandatory Replacement Parts
♦ Bolt - Transmission Support to Transmission
♦ Bolt - Transmission Support to Transmission Bracket
♦ Bolt - Pendulum Support to Transmission
♦ Bolt - Pendulum Support to Subframe
♦ Bolts - Transmission Bracket to Transmission
♦ Bolts - Transmission Mount to Transmission Bracket
♦ Lock Washer - Cable Retainer
Golf 2015 ➤ , Golf Variant 2015 ➤
Manual Transmission - Edition 12.2014
.
.
2. Transmission, Removing and Installing
77