Volkswagen Golf 2015 Repair Manual page 85

– Clean the drive axle splines and grease lightly with Grease For
Clutch Disc Shaft Splines - G 000 100- .
It must be possible to slide the clutch plate back and forth on the
input shaft.
– Check clutch release bearing for wear, replace if necessary.
Align the Transmission Support - 3282- with the Transmission
Support - Mounting Plate 39 - 3282/39- in order to install the 0A4
transmission.
– Align the arms of the Transmission Support so that they match
up with the holes in the Adjustment Plate .
– Install the Mounting Elements -A and C- ( Transmission Sup‐
port - Pins 29 - 3282/29- ) on the Adjusting Plate as illustrated.
– Place the transmission on the Engine and Gearbox Jack -
VAS6931- .
– Align the Adjustment Plate so that it is parallel to the trans‐
mission.
– Install the Transmission Support - Mounting Plate 29 -
3282/29- into the rear hole in the transmission for the pendu‐
lum support bolt.
– Position the Engine and Gearbox Jack under the vehicle. The
-arrow symbol B- on the adjusting plate points in direction of
travel.
– Remove from a new transmission or replacement transmis‐
sion right flange shaft -arrow-.
Note
Check the seal for leaks before removing the flange shaft. If
♦
the seal has leaks, replace it when installing. Refer to
⇒ 1.3 Right Seal, Replacing , page 185
If transmission fluid leaks out while removing the flange shaft,
♦
drain and refill transmission fluid on the installed transmission
and installed flange shaft. Refer to
⇒ 8 Transmission Fluid , page 125
– Attach the spindle -A- for the Seal Installer - Driver Set - 3066-
into the threaded piece on the differential.
– Insert the Seal Installer - One-Piece Seal - T10148- and se‐
cure with the nut -B-.
Note
The Seal Installer - One-Piece Seal - T10148- protects the
♦
right seal and the transmission from dirt.
An M8 x 105 mm bolt may be installed by hand into the differ‐
♦
ential threaded piece instead of a spindle -A-.
Manual Transmission - Edition 12.2014
.
.
Golf 2015 ➤ , Golf Variant 2015 ➤
2. Transmission, Removing and Installing
79