Volkswagen Golf 2015 Repair Manual page 91

– Install the transmission shift lever -A-. Refer to
⇒ Fig. Installing the Transmission Shift Lever , page 62
– Tighten the hex nut -arrow 3-. Refer to
⇒ 5.5 Overview - Shift Unit , page 96
– Coat the pin on the gearshift lever with a small amount of
grease -A-.
Allocate the grease for gearshift mechanism. Refer to the Parts
Catalog.
– Attach the shift cable to the gearshift lever.
– Replace the lock washer -arrow 2- after removing.
– Install the relay lever together with the cable retainer. Refer to
⇒ Fig. Remove the Relay Lever and the Cable Retainer. ,
page 58 .
The clip -arrow 1- secures the relay lever.
• Make sure the clips locks securely.
– Connect the selector cable to the cable retainer.
– Adjust the gearshift mechanism. Refer to
⇒ 1.6 Selector Mechanism, Adjusting , page 63
– If unclipped, carefully clip in the A/C system pipe and do not
disconnect the line system. Refer to ⇒ Heating, Ventilation
and Air Conditioning; Rep. Gr. 87 ; Refrigerant Circuit; System
Overview - Refrigerant Circuit .
– Install fuel filter. Do not open the line system. Refer to ⇒ Rep.
Gr. 20 ; Fuel Filter; Overview - Fuel Filter .
Note
If when removing the flange shaft, the transmission fluid leaks out,
drain and fill the transmission fluid for the installed transmission
and flange shaft. Refer to
– Install the battery tray, battery and the battery cover. Refer to
⇒ Electrical Equipment; Rep. Gr. 27 ; Battery; Battery, Re‐
moving and Installing .
– Install the air filter housing. Refer to ⇒ Engine Mechanical,
Fuel Injection and Ignition; Rep. Gr. 24 ; Air Filter; Air Filter
Housing, Removing and Installing .
– Install the engine cover. Refer to ⇒ Rep. Gr. 10 ; Engine
Cover; Engine Cover, Removing and Installing .
– Connect the battery and follow the procedure regarding what
to do after connecting a battery. Refer to ⇒ Electrical Equip‐
ment; Rep. Gr. 27 ; Battery; Battery, Disconnecting and
Connecting .
.
⇒ 8 Transmission Fluid , page 125
Golf 2015 ➤ , Golf Variant 2015 ➤
Manual Transmission - Edition 12.2014
.
.
.
2. Transmission, Removing and Installing
85