Volkswagen Golf 2015 Repair Manual page 84

Golf 2015 ➤ , Golf Variant 2015 ➤
Manual Transmission - Edition 12.2014
♦ Lock Washer - Gearshift Cable
♦ Nut - Coupling Rod to Stabilizer Bar
♦ Bolts - CV Boot to Inner CV Joint
♦ Seals - Transmission
Note
Refer to Transmission, Removing to get a list of the special tools
needed. Refer to ⇒ 2.1 Transmission, Removing , page 67
Pay attention to the following list for the subject - Transmission
Fluid, Checking and Filling :
Transmission Fluid, Checking and Filling
Transmis‐
Original
sion
Part
No oil outlet
Was com‐
pletely dis‐
assembled
Was parti‐
ally disas‐
sembled
• (the
trans‐
mission
housing
and the
clutch
housing
were not
separa‐
ted from
each
other)
– Use a thread cutter to carefully clean all threaded holes con‐
taining self-locking bolts to remove any locking compound
residue.
– Replace self-locking screws and nuts after removing them.
– Make sure the alignment sleeves for centering the engine/
transmission are installed inside the cylinder block. Install
them if necessary.
If the alignment sleeves are missing, it will be difficult to shift, there
will be clutch problems and the transmission may make noises
(loose rattling).
– Make sure the intermediate plate fits correctly on the engine.
78
Rep. Gr.34 - Controls, Housing
»No« »Yes«
X
X
X
before in‐
stallation
-item 3-
⇒ Item 3
(page 119)
transmis‐
sion fluid
capacity.
Refer to
⇒ 4.2 Ca‐
pacities ,
page 6 .
after instal‐
lation. Re‐
⇒ 8 Trans‐
Fluid , page
.
»Yes«
X
fer to
mission
125 .