Batteries; Precautions When Using Booster Batteries And Cables; Compressed Air; Intoxicants And Narcotics - Kohler SFGLD480 Operation & Maintenance Manual

22. BATTERIES

CAUTION
Always disconnect the battery ground connection from batteries before performing any work on the engine or
equipment. This will prevent sparks or burns when accidentally shorting an electrical connection.
Never expose batteries to open flame or electric spark. The chemical action of the battery produces
hydrogenous gas which is inflammable and explosive. Do not allow the battery fluid to contact skin, eyes,
clothes or painted surfaces. The electrolyte is a sulphuric acid solution, which could cause serious burns or
damage equipment. Wear eye protection when working with batteries.

23. PRECAUTIONS WHEN USING BOOSTER BATTERIES AND CABLES

Do not attempt to jump start an engine having a frozen battery. The battery may rupture or explode. Before
starting, examine all fill vents on the battery. If ice can be seen, or if the electrolyte fluid cannot be seen, do not
attempt to start with jump cables. Batteries, charged and discharged, should be treated carefully when using
jumper cables.
The following procedures assist in reducing sparks and explosion hazards always present in both batteries
when connecting charged batteries to discharges batteries:
- Turn off all electrical loads. Remove vent caps and lay damp cloth over open vent well of each battery. The
charged booster battery or batteries must have the same voltage capacity as the discharged battery or
batteries.
- The positive post is identified by a <<+>>, pos. and red colour and is larger in diameter than the negative
post.
The negative post is identified by a <<->> neg, and natural lead colour (grey).
-

24. COMPRESSED AIR

Compressed air or gases should never be used to clean clothing or your body. Compressed air can pierce the
skin and cause severe and very painful injury.
Never use your hand to check air, gas, or liquid flow rates, or check for leaks. Do not engage in <<horseplay>>
with air, gas or liquid hoses. Observe all applicable regulations as related to compressed gases.

25. INTOXICANTS AND NARCOTICS

CAUTION
Anybody under the influence of intoxicants and/or narcotics is hazard to themselves and other employees.
PRODUCT INFORMATION
IC-G-D-60-002e
SAFETY PRECAUTIONS FOR KOHLER GAS ENGINES
1.7
INDEX DATE
B
July 2015
O&M_2.002211.810_A_10_2016
Dep. 1
7/8