Low Beam Headlamp Bulb, Removing And Installing; Low Beam Headlamp Bulb, Removing And Installing", Page - Volkswagen Golf 2015 Repair Manual

– Remove the housing cover -1- bolts -2-.
– Remove the housing cover -1-.
– Release the Left Headlamp Beam Adjustment Motor - V48-
-1-:
♦ Turn the headlamp left in the direction of the -arrow A-.
♦ Turn the headlamp right opposite the direction of the
-arrow A-.
– Pull the Left Headlamp Beam Adjustment Motor - V48- -1- in
the direction of the -arrow C-.
– Turn the height adjustment -2- in the direction of the
-arrow B- (lower the reflector). While doing so hold the Left
Headlamp Beam Adjustment Motor - V48- -1- tensioned.
– Remove the Left Headlamp Beam Adjustment Motor - V48-
-1- from the headlamp height adjustment in the direction of the
-arrow C-.
– Disengage the connector and disconnect.
Installing
Install in the reverse order of removal while paying attention to
the following:
Caution
There is a risk of damaging the headlamp.
♦ During installation, ensure proper seating of the housing
cover. Water getting in the headlamp will cause damage.
– Connect the connector when pushing in the Left Headlamp
Beam Adjustment Motor - V48- .
– Pull the reflector rearward and push the Left Headlamp Beam
Adjustment Motor - V48- in the headlamp-height adjustment,
until it engages audibly.
– Secure the Left Headlamp Beam Adjustment Motor - V48-
-1- opposite the direction of the -arrow A-.
– Turn the height adjustment -2- opposite of the direction of the
-arrow B-. The reflector must be moveable.
– Perform a function test.
– Check and correct headlamp adjustment, if necessary. Refer
to ⇒ Maintenance ; Booklet 36.1 ; Procedure Descriptions .
Tightening Specifications
♦ Refer to ⇒ "1.1 Overview - Headlamp", page 92
1.9 Low Beam Headlamp Bulb, Removing
and Installing
The removal and installation is described for the left side. Re‐
moving and installing on the right side is identical.
The Left Low Beam Headlamp Bulb - M29- / Right Low Beam
Headlamp Bulb - M31- is only installed with halogen twin head‐
lamps.
Removing
– Turn off the ignition and all electrical equipment.
Golf 2015 ➤ , Golf Variant 2015 ➤
Electrical Equipment - Edition 12.2015
113
1. Headlamp