MOTO GUZZI V-7 700 Operating Handbook page 123

A • Headlight
WIRING DIAGRAM
(Standard headlight)
B • Town driving light
C • Main light bulb
o .
Terminal block with fuses
E • Distributing block
F •
Light switch and horn button
G • Spark plug
H - Distributor
I . Contact breaker
l • H. T. coil
M • Speedometer and warning light bulbs
N • Horn
o -
Neutral indicator cut -out
P - Stop light cut-out
a .
Oil pressure cut-ou t
R • Ignition switch
S _ Number plate and tail light
T - Plate illumination and stop light
U - Generator
V • Starter motor
Z •
Regulator
AA-
Starler motor relay
BB· Battery
•
LUBRICATION AND GENERAL MAINTENANCE
(See Chart fig. 131)
Monthly
- Check electrolyte level in battery (every 15 days in
summer). See
~
Battery
~.
Periodically
2 - Check tire pressure with a gauge (see page 10).
Aller the Ilrst 500 kms. (300 miles)
3 - Replace the crankcase oil. See
H
Engine lubrication ~ .
4 - Tighten all nuts and bolls.
5 - Check and adjust tappet play, if necessary. See
~ Tappet Adjustment ~.
6 - Check and if necessary top up oil level in crankcase.
Correcl level is in betwen the minimum and maximum
marks on the dipstick. See . Engine lubrication ~ .
Every 1000 kms. (600 miles)
7 - Lubricate cable ends. See ~ Lubrication 01 clutch,
front brake, and air cables " .
Every 3000 kms. (1800 miles)
8 -
Replace oil in cran kcase. See «Engine
l ubrl catlon ~ .
9 -
Check tappet clearance. See
~
Tappet clearance ".
10 - Check and clean spark plugs. See "spark plugs
».
11 Check oil level in gearbox and jf necessary top up.
See" Lubrication of gear box ~.
12 Check oil level in transmission box lor lubrication of
bevel gears.
If
necessary, top up.
13 - Clean petrol cocks and IiIters, carburetor lilter. and
!Iuel line to carburetors. See .. Carburation ~.
Every 10000 kms. (6000 miles)
14 Strip carburetor and check all parts. Using an air jet,
clean out all ducls. See ~ Carburation ~.
15 Change gearbox oil. See "lubrication of transmission».
16 Change rear whee l drive box oil. See " lubrication
of rear wheel -drive ...
17 Check cleanliness and tightness of all battery con-
nections and smear them with vaseline. See ..
Battery~ .
18 - Clean generator commutator using a clean cloth
slightly moistened in petrol. See «Generator ~ .
After the IIrst 20000 kms. (12000 miles)
19 - Check condition of wheel bearings and if still efficient
pack these with grease. See «Lubrication of wheel
bearings ~ .
20 -
Check condition 01 steering bearings and if still good ,
!pack with grease.
21 - Replace oil in fork inner tubes. See Lubrication of
fork.
22 - Clean starter motor commutator using a clean rag
lightly moistened in petro!.
O Mointon,,,,,.
6 SH Ell M"i!;gr.cIo 20140
O SHElL
S"" • • 90 E_P.
O SHEllllo';"" A
O SHELL 1.IJu. 33
MONTHLY C!)
EVERY
6~ ~::::'====~8:==='~='~~='~====~a:======if,l=========~~;=========='~====(.!;<~---------<~
EVERY 12000 ~
Fig. 131
121