Acura 1994 Integra Service Manual page 952

Symptom Probable Cause
Water leaks
1. Clogged drain tube.
2. Gap between glass weatherstrip and roof panel.
3. Defective or improperly installed glass weatherstrip.
4. Gap between drain seal and roof panel.
Wind noise
1. Excessive clearance between glass weatherstrip and root panel.
Motor noise
1. Loose motor.
2, Worn gear or bearing,
3. Cable assembly deformed.
Glass does not move, but motor
turns
1. Clutch out of adjustment.
2. Foreign matter stuck between guide rail and slider.
3. lnner cable loose.
4. Cable assembly not attached properly.
Glass does not move and motor
does not turn {glass can be moved
with moonroof wrench)
1 . B l o w n f u s e .
2. Faulty switch.
3, Battery run down.
4. Defective motor.
5. Faulty relay.
Glass Height Adjustment
The roof panel should be even with the glass weather-
s t r i p , t o w i t h i n 1 . 8 t O . 5 m m { O . O 7 1 O . O 2 i n } a l l t h e w a y
around. lf not, slide the sunshade back, and:
Tilt-up the glass.
Loosen the bolts and adjust the glass.
Repeat on opposite side if necessary.
ROOF PANEL
GLASS ERACKET
GLASS WEATHERSTRIP
4. Side-to-side fit of glass weatherstrip can be adjust-
ed by loosening the frame mounting bolts and mov-
ing the frame right or lett and forward or backward
by hand (see page 20-87).
GLASS BRACKET
Forward
V : Eolt localions, 6
6 x L O m m
9 . 8 N . m 1 1 . O k g f m ,
7.2 tbf.ttt
I
")
1 .
2 .
GLASS
4 ' /
12
10.5 mm lO.O7 1O.02 inl