Acura 1994 Integra Service Manual page 945

Moonroof
Troubleshooting
Symptom
Probable Cause
Water leaks
1
4
Clogged drain tube.
Gap between glass weatherstrip and roof panel.
Defective or improperly installed glass weatherstrip.
GaD between drain seal and roof panel.
Wind noise
1. Excessive clearance between glass weatherstrip and roof panel.
Motor noise
1. Loose motor.
2. Worn gear or bearing.
3. Cable assembly deformed.
Glass does not move, but motor
turns
1. Clutch out of adjustment.
2. Foreign matter stuck between guide rail and slider,
3. Inner cable loose.
4. Cable assembly not attached properly.
Glass does not move and motor
does not turn (glass can be moved
with moonroof wrench)
1 . B l o w n f u s e .
2. Faulty switch.
3. Battery run down.
4. Defective motor.
5. Faulty realy.
The roof panel should be even with the glass weather-
s t r i p , t o w i t h i n l 8 t O . 5 m m ( O . O 7 I 0 . O 2 i n ) a l l t h e
way around. It not, slide the sunshade back, and:
Y : Bolt locstions, 6
1 . Tilt-up the glass.
Loosen the bolts and adjust the glass.
Repeat on opposite side it necessary.
2 .
1 . 8 1 0 . 5 m m l O . O 7 i 0,O2 in)
i
ROOF PANEL
GLASS ERACKET
GLASS BRACKET
4 .
Side-to-side fit ot glass weatherstrip can be adjust-
ed by loosening the frame mounting bolts and mov-
ing the frame right or lelt and forward or backward
by hand (see page 2O-8O).
GLASS WEATI{ERSTRIP
f )
Glass Height Adiustment
20-78