Steering Linkage; Component Tests; Steering Column - Ford 2002 Bantam Workshop Manual

211-00-4
DIAGNOSIS AND TESTING (CONTINUED)
Condition
• Steering assist does not vary
with vehicle speed

Component Tests

Steering Linkage

Inspect the steering gear boots for cuts,
deterioration, twisting or distortion. Make sure the
boots are secure. Install new boots or clamps as
necessary.
1. Park the vehicle on a dry, even surface and
apply the parking brake. Place the steering in
the straight-ahead position.
2. With the engine running, gently turn the
steering wheel to the right and left to check
free play. Free play is measured at the
steering wheel rim and should be within the
limits stated in the specifications. If free play
exceeds the limit stated the steering linkage
Steering System — General Information
Possible Sources
• Power steering pressure (PSP)
switch.
• Circuit.
• For additional information,
refer to the Wiring Diagrams.
Petrol and Diesel.
Section 700-06 for schematic
and connector information.
or the steering column is worn, or the
backlash of the steering gear is excessive.
3. If the steering linkage is worn, install new compo-
nents as necessary.
The steering column cannot
be repaired, install a new steering column.
REFER to Section 211-04.
backlash cannot be adjusted. Install a new
steering gear. REFER to Section 211-02.
4. With the engine OFF, hold the steering wheel
firmly with both hands. Attempt to move the
steering wheel up and down and also to the
left and right without turning the wheel, to
check the steering column bearing wear,
steering, column shaft joint play and steering
wheel or steering column looseness. If free
play is detected, check the correct torque of
the steering column, coupling shaft and
steering wheel retaining bolts. The steering
column cannot be repaired, install a new

steering column.

REFER to Section 211-04.
211-00-4
Action
REFER to Section 211-03.
Steering gear
07/2001 2002 Bantam