Landoll BRILLION TURFMAKER II SL Operator's Manual page 11

ITEM 1
ITEM 4
528933
ITEM 5
528938
ITEM 6
528934
CAUTION
MOVING MACHINES CAN CAUSE INJURY. KEEP AWAY!
1. KEEP AWAY FROM MOVING TRACTORS OR IMPLEMENTS.
KEEP OTHERS AWAY.
2. DO NOT RIDE OR ALLOW OTHERS TO RIDE ON TRACTOR
OR IMPLEMENT.
3. BLOCK IMPLEMENT TO PREVENT MOVEMENT WHEN
UNHITCHED FROM TRACTOR.
4. KEEP ALL GUARDS AND SHIELDS IN PLACE WHILE
MACHINE OR PARTS ARE IN MOTION.
ITEM 8
8J309
ITEM 13
2P151
• DRAWBAR MAY RISE RAPIDLY
WHEN UNHITCHED.
• SL2 SEEDERS WITH REAR BOXES
ARE
ARE LOWERED TO THE GROUND.
• SEE OPERATOR'S MANUAL FOR
DETAILED INSTRUCTIONS.
ITEM 15
5K395
9K998
4K037
Turfmaker
ITEM 3
4K388
ITEM 7
9K788
8J309
WARNING
DO NOT GO NEAR LEAKS
High pressure oil easily punctures
skin causing serious injury,
gangrene or death.
If injured, seek emergency medical
help. Immediate surgery is
required to remove oil.
check for leaks.
Lower load or relieve hydraulic
ITEM 14
3K706
CAUTION
DRAWBAR-LIGHT WHEN ROLLERS
5K395
Figure 1-3: Safety Signs (1 of 5)
INTRODUCTION AND SAFETY INFORMATION
ITEM 2
PARKING PIN
ITEM 9
9J301
CALIBRATION OF FRONT SEED BOX
MACHINE MAY BE CALIBRATED FOR UNLISTED SEED AS FOLLOWS:
1. RAISE MACHINE AND LOCK IN TRANSPORT POSITION.
2. DISENGAGE CLUTCH (ELECTRICAL POWER IS REQUIRED
TO DISENGAGE).
3. IF EQUIPPED, CLOSE METERS OF REAR SEED BOX IF CONTAINS SEED
4. PLACE A CANVAS OR TARP UNDER MACHINE TO CATCH SEED.
5. TURN 11/16 HEX SEED SHAFT ON TRANSMISSION CLOCKWISE(CW)
AS FOLLOWS:
47 REVOLUTIONS FOR 8 FOOT SEEDER.
37 REVOLUTIONS FOR 10 FOOT SEEDER.
31 REVOLUTIONS FOR 12 FOOT SEEDER.
6. WEIGH SEED AND MULTIPLY BY 10 (20 FOR 22 TOOTH DRIVER)
FOR APPROXIMATE PLANTING RATE IN POUNDS PER ACRE.
Idler
22 Tooth
Driven
11 Tooth
Driver
Clutch Idler
Shaft
37 Tooth
Driven
22 Tooth
Driver
224187 FOR SL208, SL210, SL212 SEEDER
5K286 - (front) Seed Chart (01/2020 and Prior)
224187 - (front) Seed Chart (01/2020 and After)
CALIBRATION OF REAR SEED BOX
MACHINE MAY BE CALIBRATED FOR UNLISTED SEED AS FOLLOWS:
1. RAISE MACHINE AND LOCK IN TRANSPORT POSITION.
2. DISENGAGE CLUTCH (ELECTRICAL POWER IS REQUIRED
TO DISENGAGE).
3. CLOSE METERS OF FRONT SEED BOX IF BOX CONTAINS SEED.
4. PLACE A CANVAS OR TARP UNDER MACHINE TO CATCH SEED.
5. TURN 11/16 HEX SEED SHAFT ON TRANSMISSION CLOCKWISE(CW)
AS FOLLOWS:
47 REVOLUTIONS FOR 8 FOOT SEEDER.
37 REVOLUTIONS FOR 10 FOOT SEEDER.
31 REVOLUTIONS FOR 12 FOOT SEEDER.
6. WEIGH SEED AND MULTIPLY BY 10 (20 FOR 22 TOOTH DRIVER)
FOR APPROXIMATE PLANTING RATE IN POUNDS PER ACRE.
Idler
22 Tooth
Driven
11 Tooth
Driver
Clutch Idler
Shaft
37 Tooth
Driven
22 Tooth
Driver
* WILL CRACK SOME SEEDS AT THESE SETTINGS.
NOT RECOMMENDED: LENTILS, SORGHUM, SUDAN GRASS
224188 FOR SL208, SL210, SL212 SEEDER
224188 - (rear) Seed Chart (01/2020 and After
5K285 - (rear) Seed Chart (01/2020 and Prior)
PARKING PIN ON LEFT END OF
FRAME BEFORE UNHITCHING
FRAME WILL TIP BACKWARDS
4K039
WARNING
MOVING PART HAZARD
TO PREVENT SERIOUS INJURY FROM
MOVING PARTS:
KEEP COVERS CLOSED DURING OPERATION.
DO NOT ALLOW ANYONE TO RIDE OR CLIMB
MACHINE DURING OPERATION.
KEEP OBSERVERS AWAY.
ITEM 10
2K123
PLANTING RATES FOR FRONT SEED BOX
1. RATES ARE FOR 11 TOOTH DRIVER. DOUBLE THESE VALUES FOR 22 TOOTH DRIVER.
2. RATES ARE INTENDED AS A GUIDE ONLY. VARIATIONS IN SIZE AND CLEANLINESS WILL AFFECT RATES.
CHECK ACREAGE AND POUNDS OF SEED USED FOR BEST RESULTS.
11/16 Hex
Seed Shaft
ITEM 11
PLANTING RATES FOR REAR SEED BOX
1. RATES ARE FOR 11 TOOTH DRIVER. DOUBLE THESE VALUES FOR 22 TOOTH DRIVER.
2. RATES ARE INTENDED AS A GUIDE ONLY. VARIATIONS IN SIZE AND CLEANLINESS WILL AFFECT RATES.
CHECK ACREAGE AND POUNDS OF SEED USED FOR BEST RESULTS.
* *
23 Tooth
Driven
Idler
Rear Seed
Shaft
11/16 Hex
Seed Shaft
ITEM 12
CAUTION
BE SURE TO ENGAGE
TRACTOR. OTHERWISE
ABOUT FRONT AXLE
9J302
ITEM 16
9J302
2K123
1-5