Audi TT 2007 Workshop Manual page 78

Audi TT 2007 ➤
Direct shift gearbox 02E, front-wheel drive - Edition 12.2006
WARNING
Hot gearbox oil can cause burns.
♦ Wear safety goggles.
♦ Wear protective gloves (acid resistant).
Caution
Risk of damage to the gearbox.
♦ The engine must not be started when there is no oil in the
gearbox.
• Gearbox not in backup mode (emergency running mode)
• Vehicle must be on a 4-pillar lifting platform or standing over
an inspection pit so it is absolutely horizontal.
• Selector lever in position "P", handbrake applied.
• Engine not running.
Draining off gear oil
– Renew gear oil filter
– Release fasteners -1 ... 4- and remove centre noise insulation.
– Place used oil collection and extraction unit -V.A.G 1782- be‐
low gearbox.
– Unscrew inspection plug -A- and remove together with seal
-B-.
• The gear oil that has collected in the overflow pipe -C- will drain
off first.
– Unscrew overflow pipe and allow remaining gear oil to drain.
Filling up with gear oil
– Screw overflow pipe into inspection plug opening and tighten
to specified torque.
Caution
Take care not to mix the gear oil with different types of oil.
♦ Check that the adapter for oil filling -VAS 6262- is clean.
The gear oil for the direct shift gearbox must not be mixed
with different types of oil.
– Screw container of gear oil for direct shift gearbox onto adapter
for oil filling -VAS 6262- .
74
Rep. Gr.34 - Controls, housing
⇒ page 78 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.