Clutch; Servicing Multiple Clutch - Exploded View - Audi TT 2007 Workshop Manual

30 –

Clutch

1

Servicing multiple clutch - exploded view

♦ The clutch in the direct shift gearbox 02E consists of two sets
of plates, and is therefore referred to as a "multiple clutch". The
larger set of plates (located on the outside) is designated
"K 1" (clutch 1), and controls the torque flow for reverse gear
and gears "1", "3" and "5". The smaller set of plates (on the
inside) is designated "K 2" (clutch 2), and controls the torque
flow for gears "2", "4" and "6".
♦ Any work performed on the multiple clutch requires extra care
because all the parts are balanced and matched together in
production. If the components are rotated out of their original
positions when repairing, this will cause imbalance and impair
the smoothness of the gear-changes and reduce the service
life of the unit.
Replacement parts
1 - Multiple clutch
❑ With circlip
Caution
The clutch plates can slip
out of position inside the
multiple clutch unit.
♦ The multiple clutch unit
must not be dismantled
at present.
♦ If the drive plate (which
forms the upper section
of the multiple clutch unit)
becomes detached from
the splines in the outer
plate carrier, the clutch
plates can slip out of po‐
sition in the clutch. It will
then no longer be possi‐
ble to adjust the clutch
correctly.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
♦ The drive plate included
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with the replacement part
is not secured with the
large circlip; it is only a
close fit inside the clutch.
❑ Removing and installing
⇒ page 13
2 - Circlips
❑ 10x, with different thick‐
nesses for adjusting
multiple clutch
❑ Determining correct
thickness when instal‐
ling multiple clutch
⇒ page 18
3 - Clutch end cover
4 - Corrugated ring
Direct shift gearbox 02E, front-wheel drive - Edition 12.2006
with respect to the correctness of information in this document. Copyright by AUDI AG.
Audi TT 2007 ➤
1. Servicing multiple clutch - exploded view
11