Fuel System And Air Intake; Fuel System; Fuel Lines; Fuel Filter (Carb Models) - Polaris Ranger 500 2x4 2007 Service Manual

MAINTENANCE
7. Use this procedure to loosen or tighten the shift linkage
cable as needed.
Clockwise
Counterclockwise

FUEL SYSTEM AND AIR INTAKE

Fuel System

Gasoline is extremely flammable and explosive
under certain conditions.
Always stop the engine and refuel outdoors or in
a well ventilated area.
Do not smoke or allow open flames or sparks in
or near the area where refueling is performed or
where gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed
area. Engine exhaust fumes are poisonous and
can result loss of consciousness or death
in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.

Fuel Lines

1. Check fuel lines for signs of wear, deterioration, damage
or leakage. Replace if necessary.
2. Be sure fuel lines are routed properly and secured with
cable ties. CAUTION: Make sure lines are not kinked or
pinched.
3. Replace all fuel lines every two years.
2.14
Inside Jam Nut
Outside Jam Nut
WARNING

Fuel Filter (Carb Models)

The fuel filter should be replaced in accordance with the
Periodic Maintenance Chart or whenever sediment is visible in
the filter.
1. Remove line clamps at both ends of the filter (A).
2. Remove fuel lines from filter (A).
Fuel Pump
3. Install new filter and clamps onto fuel lines with arrow
pointed in direction of fuel flow.
4. Install clamps on fuel line.
5. Start engine and inspect for leaks.

Vent Lines

1. Check fuel tank, oil tank, carburetor, and transmission vent
lines for signs of wear, deterioration, damage or leakage.
Replace every two years.
2. Be sure vent lines are routed properly and secured with
cable ties. CAUTION: Make sure lines are not kinked or
pinched

Throttle Pedal Inspection

If the throttle pedal has excessive play due to cable stretch or
cable misadjustment, it will cause a delay in throttle speed.
Also, the throttle may not open fully. If the throttle pedal has no
play, the throttle may be hard to control, and the idle speed may
be erratic.
A
Throttle Pedal