Special Tools; Part Numbers / Descriptions - Polaris Ranger 500 2x4 2007 Service Manual

SPECIAL TOOLS

Part Numbers / Descriptions

PART NUMBER TOOL DESCRIPTION
PU-43506-A
PU-47476 Fuel Pressure Test Valve Kit
PU-47063 Digital Wrench™ Diagnostic Software
Digital Wrench
PU-47471
(PU-47470, PU-47469, PU-47468)
PU-47470 Digital Wrench
PU-47469 Digital Wrench
PU-47468 Digital Wrench
2201519 Throttle Position Sensor Tester
WARNING
•
Gasoline is extremely flammable and explosive under
certain conditions.
•
EFI components are under high pressure. Verify
system pressure has been relieved before
disassembly.
•
Never drain the fuel system when the engine is hot.
Severe burns may result.
•
Do not overfill the tank. The tank is at full capacity
when the fuel reaches the bottom of the filler neck.
Leave room for expansion of fuel.
•
Never start the engine or let it run in an enclosed area.
Gasoline powered engine exhaust fumes are
poisonous and can cause loss of consciousness and
death in a short time.
•
Do not smoke or allow open flames or sparks in or
near the area where refueling is performed or where
gasoline is stored.
•
If you get gasoline in your eyes or if you should
swallow gasoline, seek medical attention immediately.
•
If you spill gasoline on your skin or clothing,
immediately wash with soap and water and change
clothing.
•
Always stop the engine and refuel outdoors or in a
well ventilated area.
Fuel Pressure Test Kit
SmartLink Kit
™
PC Interface Cable
™
Vehicle Interface Cable
™
SmartLink Module
™
ELECTRONIC FUEL INJECTION
Fuel Pressure Tester - PU-43506-A
IMPORTANT: The EFI fuel system remains under high
pressure, even when the engine is not running.
Before attempting to service any part of the fuel
system, the pressure must be relieved. The pressure
adapter has an integrated relief valve. Connect to the
test valve and release the pressure.
Fuel Pressure Test Valve - PU-47476
Digital Wrench™ EFI Diagnostic Software
PU-47063
This dealer-only software installs on laptop computers equipped
with a CD drive and serial port connection, and is designed to
replace multiple shop tools often used to test EFI components.
It also includes step-by-step diagnostic procedures to aid
technician repair and troubleshooting.
Fuel Pressure Tester-
PU-43506-A
Test Valve
4.21
4