Suzuki Ignis Service Manual page 1673

6-3-14 ENGINE GENERAL INFORMATION AND DIAGNOSIS (Z13DT ENGINE)
B-02, Data List
As the data values given below are standard values estimated on the basis of values obtained from the normally
operating vehicles by using a scan tool, use them as reference values. Even when the vehicle is in good condi-
tion, there may be cases where the checked value does not tall within each specified data range. Therefore,
judgment as abnormal should not be made by checking with these data alone.
Also, conditions in the table below that can be checked by the scan tool are those detected by ECM and output
from ECM as commands and there may be cases where the engine or actuator is not operating (in the condi-
tion) as indicated by the scan tool.
Test Work Order Description
T01 Tester Display – Battery Voltage
• Ignition ON
• Engine OFF
• All consumers turned off
• Engine starting
• Engine running at idle speed, operating temperature
Concerned Terminals:
E27-1, E27-2, E27-3, E27-50 (For RM413D)
G88-1, G88-2, G88-3, G88-50 (For RB413D)
Yes: T02
T02 Tester Display – Main Relay
• Ignition OFF
• Ignition ON
• Engine OFF
• All consumers turned off
Concerned Terminals:
E27-4, E27-5, E27-6, E27-80 (For RM413D)
G88-4, G88-5, G88-6, G88-80 (For RB413D)
Yes: T03
T03 Tester Display – Fuel Pump
• Ignition ON
• Engine OFF
• All consumers turned off
• Wait at least 20 s
• Engine running at idle speed, operating temperature
Concerned Terminals:
E27-75 (For RM413D)
G88-75 (For RB413D)
Yes: T04
T04 Tester Display – PPS 1 Voltage
• Ignition ON
• Engine OFF
• All consumers turned off
• Accelerator pedal actuated to full load stop
• Accelerator pedal not actuated
• Accelerator pedal slightly actuated
Concerned Terminals:
E27-15, E27-32, E27-35, E27-41, E27-65, E27-83 (For RM413D)
G88-15, G88-32, G88-35, G88-41, G88-65, G88-83 (For RB413D)
Yes: T05
Nominal Value
11.0 ... 13.5 V
greater than 8.0 V
12.0 ... 15.0 V
No: C-03
OFF
ON
No: C-04
OFF
ON
No: C-06
greater than 3.80 V
less than 1.00 V
greater than 1.00 V
No: C-10