Positioning The Charging Station - Siemens SICHARGE UC 150 Operating Instructions Manual

Installation

6.2 Positioning the charging station

6.2 Positioning the charging station
To set up the charging station at the site, you need to lift the charging station from the
transport pallet. Then transport the charging station to the prepared base area.
Danger to life when walking or standing under raised loads
If hoisting gear or load handling equipment fail, a lifted load can drop. If you are in the
hazardous area under or next to the lifted load at this time, death, serious injury and
material damage may result.
• Always use hoisting gear and load handling equipment properly.
• Do not stay in the hazardous area under or next to lifted loads.
Danger to life due to improper lifting
If you lift the charging station improperly, the device may tip over. Tipping of the charging
station can cause death, serious injury and material damage.
• Only qualified persons may lift the charging station.
• Only use approved hoisting gear.
• Pay attention to the center of gravity of the charging station.
• Note the weight of the charging station.
• Only lift the charging station in a vertical position.
• The forks of the forklift must protrude on the opposite side of the charging station.
Requirement
• You have mounted the rails for the crane.
• You have removed the cable bushing plates.
• The cables for the connections protrude sufficiently from the foundation.
Position the charging station above the base
To position the charging station above the foundation, follow these steps:
1. Remove the cover on the top by loosening the 6 screws and removing the cover plate.
2. Mount the two supplied rails and fix them to the outer holes with two screws each.
3. Attach the hoisting gear to the crane eyes and lift the charging station vertically upwards
with the crane.
4. Transport the charging station in a vertical position to the base.
5. Position the charging station above the base.
Use suitable tools (e.g. wooden blocks) to secure the charging station against falling.
72
WARNING
DANGER
Operating Instructions, 02/2023, A5E50068475-AB
SICHARGE UC 150