Yamaha TMAX XP530E-A 2017 Service Manual page 160

6. Drain:
• Coolant
(from the engine and radiator)
7. Install:
• Coolant drain bolt
(along with the O-ring
Coolant drain bolt
1.6 N·m (0.16 kgf·m, 1.2 lb·ft)
8. Connect:
• Coolant reservoir hose
9. Fill:
• Cooling system
(with the specified amount of the recom-
mended coolant)
Recommended antifreeze
High-quality ethylene glycol anti-
freeze containing corrosion inhibi-
tors for aluminum engines
Mixing ratio
1:1 (antifreeze:water)
Radiator (including all routes)
1.67 L (1.77 US qt, 1.47 Imp.qt)
Coolant reservoir (up to the maxi-
mum level mark)
0.25 L (0.26 US qt, 0.22 Imp.qt)
Handling notes for coolant
Coolant is potentially harmful and should be
handled with special care.
EWA13040
WARNING
• If coolant splashes in your eyes, thorough-
ly wash them with water and consult a doc-
tor.
• If coolant splashes on your clothes, quickly
wash it away with water and then with soap
and water.
• If coolant is swallowed, induce vomiting
and get immediate medical attention.
)
New
PERIODIC MAINTENANCE
ECA13481
NOTICE
• Adding water instead of coolant lowers the
antifreeze content of the coolant. If water is
used instead of coolant, check, and if nec-
essary, correct the antifreeze concentra-
tion of the coolant.
• Use only distilled water. However, if dis-
tilled water is not available, soft water may
be used.
• If coolant comes into contact with painted
surfaces, immediately wash them with wa-
ter.
• Do not mix different types of antifreeze.
10.Install:
• Radiator cap
11.Fill:
• Coolant reservoir
(with the recommended coolant to the maxi-
mum level mark "a")
12.Install:
• Coolant reservoir cap
13.Start the engine, warm it up for several min-
utes, and then stop it.
14.Check:
• Coolant level
Refer to "CHECKING THE COOLANT LEV-
EL" on page 3-30.
TIP
Before checking the coolant level, wait a few
minutes until the coolant has settled.
15.Install:
• Footboard
• Side cover
• Fuel tank cover assembly
• Center cover
Refer to "GENERAL CHASSIS (2)" on page
4-11.
• Bottom center cowling
• Side panel
• Bottom side cowling
Refer to "GENERAL CHASSIS (1)" on page
4-1.
3-32
a