Extra Plan Operations (To Be Carried Out Possibly In Combination With Maintenance Service) - Iveco daily euro 4 Repair Manual

D E 4
AILY URO
Print 603.43.671

Extra plan operations (to be carried out possibly in combination with maintenance service)

EPI EVERY 80,000 km or 1,600 hours
- Changing the rear axle oil (1)
EP2 EVERY 240,000 km or, anyhow, every 5 years (or 4,800 hours)
- Changing the belt driving the alternator
- Changing the automatic tensioner of the belt driving the alternator
- Replacing the power steering pump and alternator drive belt automatic stretcher
- Changing the pre-heating glow plugs
TI EACH YEAR - especially in early springtime
- Check state of pollen filters.
In the case of low mileage, change the filters once a year, early each spring.
T2 EACH YEAR - before the winter season
- Check coolant density.
- Check pre-combustion chamber glow plug operation.
EVERY TWO YEARS
T3
- Change brake fluid and bleed brake fluid system.
T4 EVERY THREE YEARS - even if there is no indication of the air filter clogging
- Change cartridge and clean air filter container.
- Change engine coolant
(1)
In case of annual covered distances of less then 40,000 km, the rear axle oil shall be changed at least every two years.
2
( ) Early air cleaner obstruction is generally due to particular environmental conditions. For this reason it may need to be replaced when indicated by the
sensor regardless of the replacement interval also if not specifically stated.
(3) 11
Paraflu needs to be diluted at 50% with water, while Paraflu FE is already diluted at 50% with water.
Print 603.93.651
(2)
(1)
(2)
.
SCHEDULED MAINTENANCE
Base - March 2006
5