Battery - Iveco daily euro 4 Repair Manual

D E 4
AILY URO

BATTERY (20000)

The battery shown below has a 12Vdc 110Ah 460 A power supply voltage and is installed on the left side of the engine
compartment near the EDC control unit.
Requirements
- Case and cover in polypropylethylene plastics PR. 50.100. Matt white case.
- C.S. plugs, blacK. Grids: positive and negative made of Pb Ca.
- Cover integral polypropylene
- Separator: envelope-type polyethylene
- Battery for "tropical duty" marked with red color.
- "Environmental precautions" plate according to Law no. 126 of 10/04/91 "Standards for user information".
- Adhesive label with "Selective disposal" acc. to EEC Directive no. 93/86.
Figure 25
Fast diagnosis
Defect
Start defect
Low voltage at component leads
Electrolyte level often low
Print 603.93.651
Possible causes
1. Low battery
2. Loose, oxidized or burnt out con-
tacts
3. Starter circuit defective
1. Battery at half power
2. Oxidized connections
1. Over voltage
ELECTRIC/ELECTRONIC SYSTEM
Remedy
Check battery charge; if regular check
recharge circuit
Recover
Cf. start section
Check battery charge; if regular check
recharge circuit
Sand and replace
Check recharge circuit and/or connec-
tion tightness
37
107621
Base - March 2006