⇒ "1.1.1 Summary Of Components - Propshaft, Octavia Ii Up To; 05/2007 - Skoda Octavia II 2004 Workshop Manual

Octavia II 2004 ➤ , Octavia II 2010 ➤ , Superb II 2008 ➤ , Superb II 20 ...
Propshaft and rear final drive - Edition 10.2018
– Install the propshaft on the flange of the four-wheel drive clutch
in such a way that the markings -arrows- are on the same line.
When screwing the heat shield -2- with the intermediate bearing
make sure that the screws -1- are within the four centering tabs.
– Only screw down intermediate bearing after tightening the
propshaft.
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
– Screw the pendulum support with new screws -arrow B- and
-arrow C- onto the gearbox ⇒ Engine; Rep. gr. 10 .
– Install exhaust system and align free of stress ⇒ Engine; Rep.
gr. 26 .
– Install the noise insulation ⇒ Body Work; Rep. gr. 50 .
• If droning noises occur while driving, the following must be
observed.
• Unscrew the propshaft with flexible disk with oscillation damp‐
er from the flange of the four-wheel drive clutch and screw on
again offset by a hole.
• If the droning noises are still audible, the propshaft with flexible
disk with oscillation damper must be removed from the flange
of the four-wheel drive clutch again and offset by another hole.
Tightening torques
⇒ "1.1.1 Summary of components - propshaft, Octavia II up to
05/2007", page 16
1.6.2 Removing and installing rear flexible
disk, Octavia II as of 06/2007
Removing
Special tools and workshop equipment required
♦ Engine/gearbox jack , e.g. -V.A.G 1383/A-
♦ Counterholder - T10172-
• Work on the propshaft should be carried out on a two-pillar lift
platform.
• Before the removal, mark the position of all parts to each other.
Carry out the installation again in the same position, otherwise
the imbalance is too great, damages to the bearing and hum‐
ming noises could occur.
50
Rep. gr.39 - Final drive - rear differential
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.