Fabia II 2007 ➤ , Fabia II 2009 ➤ , Fabia II 2011 ➤ , Rapid 2011 ➤ , R ...
Gearbox 02T - Edition 05.2014
3
Repairing clutch
Fault finding power transmission - problems with the clutch and
clutch control
⇒ page 70
Special tools and workshop equipment required
♦ Counterholder - MP1-223 (3067)-
♦ Centering mandrel - T10086-
♦ Centering mandrel - MP3-475A (3190A)-
♦ Grease - G 000 100-
(Gearbox removed)
Note
Observe the fault finding of the power transmission before replacing the clutch disc and the pressure plate
♦
- problems with the clutch and clutch control
Replace the clutch discs and pressure plates if the riveting is damaged or loose.
♦
Assign the clutch disc and pressure plate in accordance with engine identification characters ⇒ Electronic
♦
Catalogue of Original Parts .
Clean the drive shaft serration and hub serration on used clutch discs. Remove corrosion and only apply a
♦
very thin layer of grease -G 000 100- on the drive shaft serration.
Subsequently move the clutch disc up and down on the drive shaft until the hub fits smoothly on the shaft.
♦
Remove all excess grease.
♦
The pressure plates are protected against corrosion and are greased. Only clean the thrust surface as
♦
otherwise the life of the clutch may be considerably reduced.
Check whether the dowel sleeves for centering the engine/gearbox are present in the cylinder block; insert
♦
if necessary.
If the dowel sleeves are not installed, there are problems with the gearshift and the clutch or the gearbox is
♦
loud.
68
.
⇒ page 70
.