Lower Crankcase - Dacia 1304 2004 Repair Manual

ENGINE AND LOWER ENGINE UNITS
10
OIL SUMP DISMOUNTING – REMOUNTING
D
ISMOUNTING
Disconnect the battery.
Drain the oil off the engine.
Dismount: engine shield and oil sump
attachement screws.
Place the crankshaft with pistons 1 and 4 to
the lower dead point.
Rotatethe front parts of the sump to the left
and lower it.
Clean the contact surfaces of the gaskets
(engine block,oil sump) or those where sealant
material has been applied.
R
EMOUNTING
Place :
- the rubber gaskets of the bearings;
- the side gaskets of the sump;
( sealant material on oil sump for engines fitted
after 01.06.1996 )
- place the oil sump so that the gaskets or
sealant material layer are not displaced;
- tighten the sump attach ement screws from
the middle towards edges;
- tighten the oil sump attachment nuts;
- perform the oil filling of the engine.
For engines fitted after 01. 06. 1996 the sealing of the oil sump is done by means of sealant
material ( instead of oil sump gaskets).
Any dismountin g of the oil sump requires replacemen t of the sealant material layer.
The sealant materials homologated by SC AUTOMOBILE DACIA SA, are the followins:
- RHODOR SEAL 5661;
- LOCTITE 5900 ( ULTRA BLAKE ).

LOWER CRANKCASE

10 - 64