Dismounting - Remounting - Dacia 1304 2004 Repair Manual

21
GEARBOX DISMOUNTING – REMOUNTING FROM THE VEHICLE
NOTE: For the vehicles equipped with injection system ,first dismount RPM
transducer attached on the clutch casing, to avoid its damaging during gearbox
dismounting.
Disconnect the battery.
Disconnect:
-starter power cable;
-supply wire of cutting relay.
Unscrew the three attachment screws of
the starter shield.
Take out the starter, by drawing it along
the shaft.
Unscrew the attachment screws of the
gearbox upper part on the engine block.
Dismount the clutch cable.
Mount the crossbar TF 509, for maintaining
the half front axe, between the shock absorber
and the suspension lower arm shaft
(GB 365,GB 51 C).
Place the vehicle on the elevator and lift
it.
Drain the oil from the gearbox by unscrewing
the threaded plug and recover it.
Dismount the front wheels.
Dismount the transmission lock pins, by
means of the GB 31 B mandrel.
Dismount by means of the TF 476 extractor:
- the steering joint;
- the upper suspension joint.
Rock the steering knuckle support and take
out the transmission off the propeller shaft.
Perform the same operations for the other
side of the car.
MANUAL GEARBOX

DISMOUNTING - REMOUNTING

21 - 12