Section 8 Parking Brake System - Geely CK Series 2007 Workshop Manual

Problem symptoms table
Use the table below to help you find the cause of the problem. The numbers indicate the priority of the likely
cause of the problem. Check each part in order. If necessary, replace these parts.
Symptom
Brake Stagnation
Parking brake operating handle
Components
1. Parking Brake Handle
Ratchet Pawl 6. Ratchet Plate
10. Adjusting Nut
13. Equalizer 14. Flat-headed Rivet
Adjustment
1. Check the parking brake handle stroke
Parking brake handle stroke: the vehicle is in reliable brake when pulling the parking brake handle up to
4~7 clicks and the brake lamp is ON. The maximum control force should be no more than 196N.
The wheel can turn freely when fully releasing the parking brake handle. Otherwise, please adjust it.
2. Parking brake handle stroke
(1) Remove parking brake handle bushing
(2) Remove the rear auxiliary console assembly
(3) Turn the adjusting nut to the right position and make sure the brake handle stroke is as specified

Section 8 Parking Brake System

1. Parking brake handle (out of adjustment)
2. Parking brake cable (stuck)
3. Parking brake shoe clearance (out of adjustment)
4. Parking brake shoes lining (cracked or distortion)
5. Return or tension spring (damaged)
2. Flat-headed Rivet
7. Connecting Lever
11. Hex Bolt Spring Washer Compo.
15. Adjusting Bolt
Suspect area
3. Pin Shaft 4. Flat-headed Rivet
8. Return Spring
12. Control Lever Boot Assembly
5. Parking
9. Plastic Bush
155